Fuse and Relay Boxes on Tractors with Operator's Cab and AutoPowr
Fuse and relay boxes on tractors with AutoPowr/IVT transmission
The fuse and relay boxes are located behind the operator's seat just below the rear window.
Press down latches (A) and lift off the trim panel.
|
|
|
|
OU12401,0000B3F -19-01JUL02-1/12
|
|
A-Relay box K01
B-Relay box K02
C-Fuse box F03
D-Fuse box F04
E-Fuse box F05
F-Fuse box F06
G-Fuse box F07
H-Relay box K08
I-Relay box K09
J-Relay box K10
|
|
|
|
OU12401,0000B3F -19-01JUL02-2/12
|
Relays (relay box K01) on tractors with AutoPowr/IVT transmission
K01/1
Relay for accessories
K01/2
Relay for power supply to electronics
K01/3
Relay for accessories
K01/4
Acoustic alarm
|
|
|
|
OU12401,0000B3F -19-01JUL02-3/12
|
Relays (relay box K02) on tractors with AutoPowr/IVT transmission
K02/1
Enable relay
K02/2
Alternator relay
K02/3
Relay for LTC coolant pump
K02/4
Not used
K02/5
Relay for power supply to E-ICV
K02/6
Relay for power supply to E-SCV 3, E-SCV 4
K02/7
Relay for power supply to E-SCV 1, E-SCV 2
|
|
|
|
OU12401,0000B3F -19-01JUL02-4/12
|
Fuses (fuse box F03) on tractors with AutoPowr/IVT transmission
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a higher rating than the one already installed.
F03/01
10-amp Basic Control Unit (BCU) (power supply)
F03/02
10-amp Basic Control Unit (BCU) (PTO, front-wheel drive, differential lock, HMS II, handbrake, wheel-speed sending unit, radar)
F03/03
20-amp right-hand turn signal, hazard warning lights
F03/04
20-amp left-hand turn signal
F03/05
Not used
F03/06
10-amp brake lights
F03/07
20-amp brake switch
F03/08
10-amp controller for suspended front axle (SFA) (battery voltage)
F03/09
20-amp LTC coolant pump (older tractors)
F03/10
20-amp power supply to E-ICV
F03/11
10-amp power supply to E-SCV 3, E-SCV 4
F03/12
10-amp power supply to E-SCV 1, E-SCV 2
F03/13
10-amp E-SCV/E-ICV controller (SIC) (battery voltage)
F03/14
10-amp JDLink, GreenStar
F03/15
10-amp E-SCV/E-ICV controller (SIC) (power supply)
F03/16
20-amp heated rear window
|
|
|
|
OU12401,0000B3F -19-01JUL02-5/12
|
Fuses (fuse box F04) on tractors with AutoPowr/IVT transmission
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a higher rating than the one already installed.
F04/01
10-amp, Engine Control Unit (ECU) (power supply)
F04/02
20-amp Engine Control Unit (ECU) (battery voltage)
F04/03
Not used
F04/04
15-amp main switch (BAT)
F04/05
30-amp accessories
F04/06
30-amp, power supply for electronics
F04/07
30-amp accessories
F04/08
20-amp fuel preheater
F04/09
10-amp basic informator, controller for suspended front axle (SFA) (power supply)
F04/10
10-amp basic informator (battery voltage)
F04/11
10-amp fuel transfer pump
F04/12
10-amp performance monitor (PRF)
F04/13
10-amp CAN BUS terminator, service socket
F04/14
10-amp User Interface Controller (UIC) (power supply)
F04/15
10-amp Transmission Control Unit (TCU) (power supply)
F04/16
Not used
|
|
|
|
OU12401,0000B3F -19-01JUL02-6/12
|
Fuses (fuse box F05) on tractors with AutoPowr/IVT transmission
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a higher rating than the one already installed.
F05/01
10-amp air-conditioning system
F05/02
10-amp 2-pin plug for front loader
F05/03
10-amp Park Lock Controller (PLC) (power supply)
F05/04
10-amp Park Lock Controller (PLC) (battery voltage)
F05/05
10-amp Transmission Control Unit (TCU) (battery voltage)
F05/06
Not used
F05/07
Not used
F05/08
10-amp windshield wiper and washer
F05/09
10-amp rear window wiper and washer
F05/10
10-amp electrical rear-view mirror
F05/11
10-amp GreenStar, Tractor Equipment Controller (TEC) (power supply)
F05/12
10-amp dome light, radio (battery voltage)
F05/13
20-amp blower
F05/14
20-amp blower
F05/15
10-amp 3-terminal socket, socket strip (power supply)
F05/16
30-amp 3-terminal socket, socket strip (battery voltage)
|
|
|
|
OU12401,0000B3F -19-01JUL02-7/12
|
Fuses (fuse box F06) on tractors with AutoPowr/IVT transmission
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a higher rating than the one already installed.
F06/01
10-amp horn
F06/02
10-amp cigarette lighter
F06/03
10-amp operator's seat
F06/04
10-amp radio (power supply)
F06/05
10-amp shift console light, radio lighting
F06/06
10-amp beacon light
F06/07
10-amp front-corner worklights
F06/08
10-amp worklights on fender
F06/09
10-amp inner worklight on rear of cab roof
F06/10
10-amp outer worklight on rear of cab roof
F06/11
10-amp inner worklight on front of cab roof
F06/12
10-amp outer worklight on front of cab roof
F06/13
Fuse tester
F06/14
Not used
F06/15
Not used
F06/16
15-amp light switch (terminal B)
|
|
|
|
OU12401,0000B3F -19-01JUL02-8/12
|
Fuses (fuse box F07) on tractors with AutoPowr/IVT transmission
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a higher rating than the one already installed.
F07/01
Not used
F07/02
Not used
F07/03
Not used
F07/04
10-amp worklights on cab frame
F07/05
Not used
F07/06
10-amp dipped-beam headlight, left
F07/07
10-amp dipped-beam headlight, right
F07/08
15-amp full-beam headlights
F07/09
30-amp lights on cab frame
F07/10
10-amp r.h. tail light, l.h. clearance light, license plate light
F07/11
10-amp l.h. tail light, r.h. clearance light
F07/12
10-amp headlights
F07/13
10-amp dipped beam, left (lights on cab frame)
F07/14
10-amp dipped beam, right (lights on cab frame)
F07/15
30-amp headlights
F07/16
15-amp full-beam headlights
|
|
|
|
OU12401,0000B3F -19-01JUL02-9/12
|
Relays (relay box K08) on tractors with AutoPowr/IVT transmission
K08/1
Relay for full-beam headlights
K08/2
Relay for dipped-beam headlights
K08/3
Relay for lights on cab frame
K08/4
Relay for headlights and worklights on cab frame
K08/5
Relay for worklights on front of cab roof
K08/6
Relay for worklights on rear of cab roof
K08/7
Relay for worklights on front corners and fenders
|
|
|
|
OU12401,0000B3F -19-01JUL02-10/12
|
Relays (relay box K09) on tractors with AutoPowr/IVT transmission
K09/1
3-amp lighting diode
K09/1
1-amp diode for power supply to electronics
K09/2
3-amp CAN-BUS diode
K09/2
1-amp CAN-BUS diode
K09/3
Relay for fuel preheater
K09/4
Relay for air-conditioning system
K09/5
Not used
K09/6
Not used
K09/7
Not used
|
|
|
|
OU12401,0000B3F -19-01JUL02-11/12
|
Relays (relay box K10) on tractors with AutoPowr/IVT transmission
K10/1
Blower relay
K10/2
Acoustic alarm for park lock
K10/3
Relay for 3-terminal socket, power outlet strip
K10/4
Plug for "come home" mode
|
|
|
|
OU12401,0000B3F -19-01JUL02-12/12
|
|
