Fuse and Relay Boxes on Tractors with Operator's Cab but without AutoPowr
Fuse and relay boxes
NOTE:
Depending on how the tractor is equipped, it may not have all the fuses and relays shown below.
The fuse and relay boxes are located behind the operator's seat just below the rear window.
Press down latches (A) and lift off the trim panel.
|
|
|
|
OULXE59,0010668 -19-29JUL04-1/12
|
|
A-Relay box K01
B-Relay box K02
C-Fuse box F03
D-Fuse box F04
E-Fuse box F05
F-Fuse box F06
G-Fuse box F07
H-Relay box K08
I-Relay box K09
J-Relay box K10
|
|
|
|
OULXE59,0010668 -19-29JUL04-2/12
|
Relays (relay box K01)
K01/1
Accessory relay
K01/2
Electronic power supply relay
K01/3
Accessory relay
K01/4
Acoustic alarm
|
|
|
|
OULXE59,0010668 -19-29JUL04-3/12
|
Relays (relay box K02)
K02/1
Not used
K02/2
Alternator relay
K02/3
Not used
K02/4
Not used
K02/5
E-ICV power supply relay
K02/6
E-SCV 3 and E-SCV 4 power supply relay
K02/7
E-SCV 1 and E-SCV 2 power supply relay
|
|
|
|
OULXE59,0010668 -19-29JUL04-4/12
|
Fuses (fuse box F03)
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a rating higher than the one already installed.
F03/01
10-amp, Basic Control Unit (power supply)
F03/02
10-amp, Basic Control Unit (BCU) (PTO, front-wheel drive, differential lock, HMS II, handbrake, wheel-speed sending unit, radar)
F03/03
20-amp, right turn signal, hazard warning lights
F03/04
20-amp, left turn signal
F03/05
Not used
F03/06
10-amp, brake light
F03/07
20-amp, brake switch
F03/08
10-amp, controller for suspended front axle (SFA) (battery voltage)
F03/09
Not used
F03/10
20-amp, power supply to E-ICV
F03/11
10-amp, power supply to E-SCV 3, E-SCV 4
F03/12
10-amp, power supply to E-SCV 1, E-SCV 2
F03/13
10-amp, SIC controller (battery voltage)
F03/14
10-amp, JDLink, GreenStar
F03/15
10-amp, SIC controller (power supply)
F03/16
20-amp, heated rear window
|
|
|
|
OULXE59,0010668 -19-29JUL04-5/12
|
Fuses (fuse box F04)
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a rating higher than the one already installed.
F04/01
10-amp, Engine Control Unit (power supply)
F04/02
10-amp, Engine Control Unit (battery voltage)
F04/03
10-amp, GreenStar (power supply)
F04/04
15-amp, main switch (BAT)
F04/05
30-amp, accessories
F04/06
30-amp, power supply for electronics
F04/07
30-amp, accessories
F04/08
20-amp, fuel preheater
F04/09
10-amp, basic informator, SFA controller (power supply)
F04/10
10-amp, basic informator (battery voltage)
F04/11
10-amp, fuel pump, injection pump shut-off valve
F04/12
10-amp, performance monitor PRF, JDLink (power supply)
F04/13
10-amp, CAN BUS terminator, service socket
F04/14
Not used
F04/15
Not used
F04/16
Not used
|
|
|
|
OULXE59,0010668 -19-29JUL04-6/12
|
Fuses (fuse box F05)
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a rating higher than the one already installed.
F05/01
10-amp, air-conditioning system, relay for fan, ClimaTrak (power supply)
F05/02
10-amp, 2-pin plug for front loader
F05/03
Not used
F05/04
10-amp, EPC controller (power supply)
F05/05
10-amp, EPC controller (battery voltage)
F05/06
10-amp, EPC controller (gear selection)
F05/07
10-amp, accessories
F05/08
10-amp, windshield wiper and washer
F05/09
10-amp, rear window wiper and washer
F05/10
10-amp, electric rear-view mirrors, signal socket
F05/11
10-amp, GreenStar, TEC controller (power supply)
F05/12
10-amp, dome light, radio (battery voltage)
F05/13
20-amp, fan
F05/13
30-amp, ClimaTrak (fan)
F05/14
20-amp, fan
F05/14
10-amp, ClimaTrak (battery voltage)
F05/15
10-amp, 3-terminal socket, socket strip (power supply)
F05/16
30-amp, 3-terminal socket, socket strip (battery voltage)
|
|
|
|
OULXE59,0010668 -19-29JUL04-7/12
|
Fuses (fuse box F06)
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a rating higher than the one already installed.
F06/01
10-amp, horn
F06/02
10-amp, cigarette lighter
F06/03
15-amp, operator's seat
F06/04
10-amp, radio (power supply)
F06/05
10-amp, shift console light, radio lighting
F06/06
10-amp, beacon light
F06/07
10-amp, front corner work light
F06/08
10-amp, work lights on fenders (rear-facing)
F06/09
15-amp, outer work light on rear of cab roof or Xenon (HID) work light on right rear of cab roof
F06/10
15-amp, inner work light on rear of cab roof or Xenon (HID) work light on left rear of cab roof
F06/11
10-amp, outer work light on front of cab roof
F06/12
10-amp, inner work light on front of cab roof
F06/13
Fuse tester
F06/14
10-amp, AutoTrac (power supply)
F06/15
10-amp, AutoTrac (battery voltage)
F06/16
15-amp, light switch (pin B)
|
|
|
|
OULXE59,0010668 -19-29JUL04-8/12
|
Fuses (fuse box F07)
IMPORTANT:
To prevent unnecessary damage to the electrical system, never use a fuse with a rating higher than the one already installed.
F07/01
Not used
F07/02
Not used
F07/03
Not used
F07/04
10-amp, work lights on cab frame
F07/05
Not used
F07/06
10-amp, dipped-beam headlight, left
F07/07
10-amp, dipped-beam headlight, right
F07/08
15-amp, full-beam headlights
F07/09
30-amp, lights on cab frame
F07/10
10-amp, r.h. tail light, l.h. clearance light, license plate light
F07/11
10-amp, l.h. tail light, r.h. clearance light
F07/12
10-amp, headlights
F07/13
10-amp, dipped beam, left (lights on cab frame)
F07/14
10-amp, dipped beam, right (lights on cab frame)
F07/15
30-amp, headlights
F07/16
15-amp, full-beam headlights
|
|
|
|
OULXE59,0010668 -19-29JUL04-9/12
|
Relays (relay box K08)
K08/1
Relay for full-beam headlights
K08/2
Relay for low-beam headlights
K08/3
Relay for lights on cab frame
K08/4
Relay for headlights and work lights on cab frame
K08/5
Relay for work lights on front of cab roof
K08/6
Relay for work lights on rear of cab roof
K08/7
Relay for front corner/rear of fender work lights
|
|
|
|
OULXE59,0010668 -19-29JUL04-10/12
|
Relays (relay box K09)
K09/1
3-amp, lighting diode
K09/1
1-amp, diode for power supply to electronics
K09/2
3-amp, CAN-BUS diode
K09/2
1-amp, CAN-BUS diode
K09/3
Fuel preheater relay
K09/4
Air-conditioning system relay
K09/5
Transmission enable relay
K09/6
Not used
K09/7
Not used
|
|
|
|
OULXE59,0010668 -19-29JUL04-11/12
|
Relays (relay box K10)
K10/1
Fan relay
K10/2
ClimaTrak bridging plug
K10/3
Relay for 3-terminal socket, power outlet strip
K10/4
Plug for "come home" mode
|
|
|
|
OULXE59,0010668 -19-29JUL04-12/12
|
|
