|
Engine - Remove any dirt from area surrounding the engine
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Check engine oil level
|
•
|
•
|
—
|
—
|
—
|
—
|
—
|
—
|
|
Fuel filter - Drain water and residues
|
•
|
•
|
—
|
—
|
—
|
—
|
—
|
—
|
|
Check coolant level
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Cooling system/air-conditioning system - Clean the radiator
and condenser, fins and screens
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Air brake system - Check compressed air tank for condensed water.
If condensed water drains out, replace air-drier cartridge, otherwise
do this every 1500 hours or every 2 years at the latest (see Service
- Every 1500 Hours or 2 Years).
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Transmission/hydraulic system - Check oil level
|
•
|
•
|
•
|
—
|
—
|
—
|
—
|
•
|
|
Check leak oil tanks (if equipped)
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Check brakes
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Lights - Check that all lights and headlights are functioning
properly
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front hitch - Lubricate cylinder and three-point hitch
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Adjustable front axle - Lubricate the grease fittings
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front-wheel drive axle - Lubricate pivot bearing
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front-wheel drive axle - Lubricate all universal joints including
universal-jointed shaft from transmission to front-wheel drive axle
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Suspended front-wheel drive axle - Lubricate hydraulic cylinder
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Lubricate pivoting fenders, and perform operational check
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Lubricate all wagon hitches
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Three-point hitch - Lubricate lift links and rockshaft
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Lubricate the rear axle bearings (if equipped)
|
•*
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Retrieve the diagnostic trouble codes, rectify errors, and then
delete the diagnostic trouble codes.
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Open operator's station - Have torques of attaching screws checked
by an authorized dealer (see Service - Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Drawbar - Check torque of attaching screws (see Service - Every
500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Height-adjustable trailer hitch - Check torque on attaching
screws (see Service - Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Trailer hitch - Check torques of attaching screws (see Service
- Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Pick-up hitch - Check torque of attaching screws (see Service
- Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front hitch - Attaching frame, check torque of attaching screws
(see Service - Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
John Deere™ front loader mounting frame - Check torques
of attaching screws (see operator's manual and installation instructions
of the front loader).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Check air intake hoses for leaks (see Service - Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Change hydraulic oil filter (or whenever the yellow Caution
light flashes and corresponding information appears in the instrument
panel. See Service - Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Change transmission oil filter (or whenever the yellow Caution
light flashes and corresponding information appears in the instrument
panel. See Service - Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front-wheel drive axle - Axle housing, oil change (see Service
- Every 1500 Hours or 2 Years).
|
|
•
|
—
|
•
|
•
|
•
|
•
|
—
|
|
Front-wheel drive axle - Final drives without brake, oil change
(see Service - Every 1500 Hours or 2 Years).
|
|
•
|
—
|
•
|
•
|
•
|
•
|
—
|
|
Front-wheel drive axle - Final drives with brake, oil change
(see Service - Every 500 Hours).
|
|
•
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Check the movement inhibitor
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
PTO actuation - Check safety device
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Fuse box - Visually inspect and clean
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Lights - Check settings of headlights
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Fuel tank - Drain water and residues
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Change fuel filter
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Change Engine Oil Filter
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Change engine oil
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Engine - Replace filter on crankcase ventilation (oil separator)
(only with tractors with exhaust aftertreatment system (Final Tier
4 / Stage IV)
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front PTO - Change oil filter
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front-wheel drive axle - Axle housing, check oil level
|
|
|
•
|
—
|
—
|
—
|
—
|
•
|
|
Front-wheel drive axle - Final drives without brake, check oil
level
|
|
|
•
|
—
|
—
|
—
|
—
|
•
|
|
Wagon hitches - Check all components for wear; check that all
components function properly
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Check that all accessible ground cables are secure
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Engine - Check drive belt for wear (rubbing)
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Cab - Check all rubber seals of the doors and windows as well
as the cable feedthroughs for proper seating, wear, and brittleness.
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Cab - Check function of all closing mechanisms of the doors
and windows.
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Cab - Change the activated carbon filter every 500 hours or
after 1 year at the latest (if equipped).
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Have brake system bled and checked by an authorized dealer.
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Foot brake - Operational check
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Park brake - Operational check
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Air brake system - Check the time needed for filling
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Air brake system - Check function of park brake
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Air brake system - Visual inspection and operational check of
couplers
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Park lock - Operational check
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Adjustable front axle - Tighten axle bolts
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Wheels - Front and rear wheels, check torques of attaching screws
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Wheels - Wheel disk to rim, check torques of attaching screws
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Wheels - Wheel weights, check torques of attaching screws
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Wheels - Dual wheel attachment, check torques of attaching screws
(see manufacturer's specifications)
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front PTO - Have torque on torsion damper attaching screws checked
by an authorized dealer.
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Rear PTO, lubricate PTO stub shaft support (with pivoting PTO
stub shaft)
|
|
|
•
|
•
|
•
|
•
|
•
|
•
|
|
Front-axle suspension - Have pressure accumulator checked by
an authorized dealer
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Engine air cleaner - Change the primary filter (whenever the
yellow Caution light flashes and corresponding information appears
in the instrument panel, or every 2 years)
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Transmission - Clean intake screens
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Transmission/Hydraulic system - Change the oil
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Front PTO - Change the oil
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Replace cab air filter (always when the primary filter of the
engine air cleaner is replaced or every 2 years)
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Cab - Replace recirculation air filter (always when the primary
filter of the engine air cleaner is replaced or every 2 years)
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Air brake system - Change the receiver-drier cartridge (an earlier
change may be necessary if condensed water drains out when checking
compressed-air tank, or every 2 years).
|
|
|
|
•
|
•
|
•
|
•
|
—
|
|
Engine - Have valves adjusted by authorized dealer
|
|
|
|
|
•
|
—
|
•
|
—
|
|
Engine air cleaner - Change the secondary element (no later
than at every fourth change of the primary element or every 5 years)
|
|
|
|
|
|
•
|
—
|
—
|
|
Have DEF filters replaced by an authorized dealer (or every
3 years)
|
|
|
|
|
|
•
|
—
|
—
|
|
Cooling system - Change the coolant (if COOL-GARD™ II
is used and coolant is checked annually)**
|
|
|
|
|
|
|
•
|
—
|
|
Front-axle suspension - Have pressure accumulator replaced by
an authorized dealer
|
|
|
|
|
|
|
|
•
|
|
* Only necessary when operating the tractor in extremely wet
and muddy conditions
** Use of a coolant other than COOL-GARD™ II reduces the
service interval to 2000 hours, or, if COOL-GARD™ is used, the
service interval is reduced to 3000 hours. Also comply with Section
80, which provides more information on the use of coolant. See also Note Regarding the Service Interval for Engine Coolant in this section.
|