| Item |
Daily or
10 Hours |
250 Hours |
750 Hours |
| Check Engine Oil and Coolant Levels |
· |
|
|
| Drain Water Separator |
· |
|
|
| Check Transmission, Hydraulic, and Axle Oil (Powershift) Levels |
· |
|
|
| Lubricate Hitch Components |
· |
|
|
| Lubricate Hinge Pins |
· |
|
|
| Inspect Tires and Tighten Wheel Bolts |
· |
|
|
| Change Engine Oil and Filter * |
|
· |
|
| Replace Fuel Filter (9200, 9300, 9400) ** |
|
· |
|
| Check Manual Brakes |
|
· |
|
| Service Batteries |
|
· |
|
| Check Neutral Start System |
|
· |
|
| Clean Cab Air and Recirculation Filters ** |
|
· |
|
| Lubricate Hitch Sensor |
|
· |
|
| Lubricate Telescoping Drive Shafts |
|
· |
|
| Lubricate Lower Driveline Bearing and Shaft |
|
· |
|
| Lubricate PTO Drive Shaft |
|
· |
|
| Replace Hydraulic Filter, Clean Reservoir Screen, and Replace Reservoir Breather Filter ** |
|
|
· |
| Replace Transmission Filter ** |
|
|
· |
| Replace Axle Filter (Powershift) *** |
|
|
· |
| Check Coolant and Add Coolant Conditioner |
|
|
· |
| Clean Water Separator ** |
|
|
· |
| Replace Primary and Secondary Fuel Filters (9100) ** |
|
|
· |
| Replace Fuel Pre-filter ** |
|
|
· |
| Clean Fuel Tank Vent Filter (9100)** |
|
|
· |
| Clean Engine Air Intake System |
|
|
· |
| |
| * Change engine oil for the first time after 100 hours maximum of operation (See Engine Break-in Section), then every 250 hours thereafter. If PLUS-50 Oil is used with a John Deere filter, oil change interval may be extended by 50 percent to 375 hours |
| ** Interval can vary according to operating conditions |
| *** Change axle filter for the first time after 100 hours maximum operation, then every 750 hours thereafter |