| Item |
Daily or
10 Hours |
250 Hours |
750 Hours |
| Check Engine Oil and Coolant Levels |
· |
|
|
| Drain Water Separator |
· |
|
|
| Check Transmission, Hydraulic, and Axle Oil (Powershift) Levels |
· |
|
|
| Lubricate Hitch Components |
· |
|
|
| Lubricate Hinge Pins |
· |
|
|
| Inspect Tires and Tighten Wheel Bolts |
· |
|
|
| Change Engine Oil and Filter * |
|
· |
|
| Replace Fuel Filter (9200, 9300, 9400) ** |
|
· |
|
| Check Manual Brakes |
|
· |
|
| Service Batteries |
|
· |
|
| Check Neutral Start System |
|
· |
|
| Check PARK Position - 12 Speed Syncro and 24-Speed PowerSync Transmissions |
|
· |
|
| Check PARK Brake - Powershift Transmission |
|
· |
|
| Clean Cab Air and Recirculation Filters ** |
|
· |
|
| Lubricate Telescoping Drive Shafts |
|
· |
|
| Lubricate Lower Driveline Bearing and Shaft |
|
· |
|
| Lubricate PTO Drive Shaft |
|
· |
|
| Replace Hydraulic Filter ***, Clean Reservoir Screen, and Replace Reservoir Breather Filter ** |
|
|
· |
| Replace Transmission Filter *** |
|
|
· |
| Replace Axle Filter (Powershift) *** |
|
|
· |
| Test Coolant and Add Coolant Conditioner |
|
|
· |
| Clean Water Separator ** |
|
|
· |
| Replace Primary and Secondary Fuel Filters (9100) ** |
|
|
· |
| Replace Fuel Pre-filter ** |
|
|
· |
| Clean Fuel Tank Vent Filter (9100) ** |
|
|
· |
| Clean Engine Air Intake System |
|
|
· |
| |
| * INITIAL oil and filter change is 100 hours maximun of operation. SCHEDULED interval (250 hours) can be extended to 375 hours if PLUS-50 oil and John Deere Filter are used |
| ** Interval can vary according to operating conditions |
| *** INITIAL filter change is 100 hours maximun of operation. |