Service Interval Chart-Daily or 10 Hours/100 Hours/250 Hours/500 Hours/750 Hours

Item Daily or 10 Hours 100 Hour 250 Hours 500 Hours 750 Hours
Check Engine Oil Level ·        
Engine Coolant Level ·        
Drain Water and Sediment from Fuel Filter or Water Separator ·        
Check Transmission-Hydraulic Oil Level ·        
Lubricate MFWD Axle, if Equipped with AutoTrac System ·        
Drain Trailer Air Brake Air Tank (if equipped) ·        
Inspect Tires ·        
Lubricate Hitch Components* ·        
Lubricate MFWD Kingpins, Tie Rod Ends and Axle Pivot** · · ·    
Lubricate Non-Driving (2WD) Axle Tie Rod Ends, Axle Pivot and Steering Spindles/Cylinder Ends**   · ·    
Lubricate Non-Driving (2WD) Axle, Wheel Bearings**   · ·    
Lubricate Triple Link Suspension (if equipped)** · · ·    
Lubricate Front and Rear PTO Shafts** · · ·    
Lubricate Rear Axle Bearings** · · ·    
Lubricate Front Hitch** · · ·    
Check Torque on Wheel and Wheel Weight Bolts****** · · ·    
Air Intake Hoses, Check   · ·    
Check Coolant Level (Coolant De-aeration Tank)   ·      
Change Engine Oil and Filter*****   · ·    
Replace Transmission-Hydraulic Filters****   ·     ·
Batteries, Check     ·    
Drain Fuel Tank Sump     ·    
Check Neutral Start System     ·    
Check Brakes     ·    
Check Transmission PARK Position     ·    
Check Front PTO Housing Oil Level (if equipped)     ·    
Check MFWD Axle Housing and Wheel Hub Oil Level     ·    
Clean Cab Air and Recirculation Filters***     ·    
Replace Fuel Filters***     ·    
Service Air Intake System***         ·
Check Engine Idle Speed         ·
Test Coolant and Add Coolant Conditioner         ·
Clean Fuel Tank Vent Filter         ·
MFWD Axle Breather Clean         ·
 
* Lubrication of rear hitch should be daily if used frequently. Extended period if the hitch is not used regularly.

 

OUMX005,0001609 -19-02JUN05-1/2

Item Daily or 10 Hours 100 Hour 250 Hours 500 Hours 750 Hours
** Lubricate daily or at 10 hours when operating in extremely wet and muddy conditions, or with Heavy Duty service using front loaders, front hitch or front tanks. If not operating in these conditions perform service at 250 hours.
*** Interval can vary according to operating conditions.
**** Perform INITIAL hydraulic-transmission filter replacement at 100 hours maximum operation. Scheduled intervals can vary according to operating conditions.
***** Normal change interval is 250 hours. It can be extended to 500 hours if PLUS-50 oil and a John Deere filter are used.
****** Tighten wheel bolts at 3 hours, 10 hours and daily for the first week of operation.

 

OUMX005,0001609 -19-02JUN05-2/2