| |
7630 |
7730 |
7830 |
7930 |
| POWER |
|
| PTO (Factory Observed) |
104 kW (140 hp) |
112 kW (152 hp) |
123 kW (165 hp) |
134 kW (180 hp) |
| Rated Speed |
2100 |
2100 |
2100 |
2100 |
| ENGINE |
|
| Type |
Diesel |
Diesel |
Diesel |
Diesel |
| Cylinders |
In-line 6 |
In-line 6 |
In-line 6 |
In-line 6 |
| Aspiration |
Turbocharged and Air-to-Air Charge Air Intercooling with Exhaust Gas Recirculation (EGR) |
Turbocharged and Air-to-Air Charge Air Intercooling with Exhaust Gas Recirculation (EGR) |
Turbocharged and Air-to-Air Charge Air Intercooling with Exhaust Gas Recirculation (EGR) |
Turbocharged and Air-to-Air Charge Air Intercooling with Exhaust Gas Recirculation (EGR) |
| Lubrication |
Full pressure, full flow filtration |
Full pressure, full flow filtration |
Full pressure, full flow filtration |
Full pressure, full flow filtration |
| Displacement |
6.8 L (414 in.3) |
6.8 L (414 in.3) |
6.8 L (414 in.3) |
6.8 L (414 in.3) |
| Bore |
106.5 mm (4.2 in.) |
106.5 mm (4.2 in.) |
106.5 mm (4.2 in.) |
106.5 mm (4.2 in.) |
| Stroke |
127 mm (5.00 in.) |
127 mm (5.00 in.) |
127 mm (5.00 in.) |
127 mm (5.00 in.) |
| Compression Ratio |
17.0:1 |
17.0:1 |
17.0:1 |
17.0:1 |
| Slow Idle Speed |
875±10 rpm |
875±10 rpm |
875±10 rpm |
875±10 rpm |
| Fast Idle Speed |
2200±25 rpm |
2200±25 rpm |
2200±25 rpm |
2200±25 rpm |
| CAPACITIES |
|
| Fuel Tank |
|
| Without Right-Hand Step |
390 L (103 gal) |
390 L (103 gal) |
390 L (103 gal) |
390 L (103 gal) |
| With Right-Hand Step |
356 L (94 gal) |
356 L (94 gal) |
356 L (94 gal) |
356 L (94 gal) |
| Cooling System |
29.3 L (31.1 qt) |
29.3 L (31.1 qt) |
29.3 L (31.1 qt) |
29.3 L (31.1 qt) |
| Crankcase, including Filter |
26 L (27.5 qt) |
26 L (27.5 qt) |
26 L (27.5 qt) |
26 L (27.5 qt) |
| Front PTO Oil |
8 L (8.5 qt) |
8 L (8.5 qt) |
8 L (8.5 qt) |
8 L (8.5 qt) |
| Transmission-Hydraulic System |
108 L (28.5 gal) |
108 L (28.5 gal) |
108 L (28.5 gal) |
108 L (28.5 gal) |
| MFWD |
|
| Regular Axle Housing |
14.4 L (15.2 qt) |
14.4 L (15.2 qt) |
14.4 L (15.2 qt) |
14.4 L (15.2 qt) |
| Standard Wheel Hubs |
1.9 L (2 qt) |
1.9 L (2 qt) |
1.9 L (2 qt) |
1.9 L (2 qt) |
| Wheel Hubs for HD Axle |
3.8 L (4 qt) |
3.8 L (4 qt) |
3.8 L (4 qt) |
3.8 L (4 qt) |
| FUEL SYSTEM |
|
| Fuel Injection Type |
High Pressure Common Rail (HPCR) |
High Pressure Common Rail (HPCR) |
High Pressure Common Rail (HPCR) |
High Pressure Common Rail (HPCR) |
| Injection Pump |
HP3 |
HP3 |
HP3 |
HP3 |
| Air Cleaner |
Dry type with safety element and pre-cleaner |
Dry type with safety element and pre-cleaner |
Dry type with safety element and pre-cleaner |
Dry type with safety element and pre-cleaner |
|
|
OU1092A,00003D3 -19-01MAY07-1/4
|
| |
7630 |
7730 |
7830 |
7930 |
| POWER |
|
| COOLING SYSTEM |
|
| Type |
69 kPa (0.7 bar) (10 psi) Centrifugal Pump |
| Fan |
Viscous Drive |
| Thermostats |
Three, Heavy Duty |
|
|
OU1092A,00003D3 -19-01MAY07-2/4
|
| |
7630 |
7730 |
7830 |
7930 |
| HYDRAULIC SYSTEM |
| Type |
Closed center, power on demand, load sensing pump |
| Pump |
High pressure, axial piston, pressure/flow compensation |
| Pump Displacement |
45 cm3 (2.75 in.3) Standard
63 cm3 (3.85 in.3) Optional |
| Maximum Pressure |
20,000 kPa (200 bar) (2900 psi) |
| Pump output |
121 L/min (32 gpm) Standard
174 L/min (45 gpm) Optional |
| Steering |
Load sensing, hydrostatic, flow metering |
| Available Flow at One SCV |
114 L/min (30 gpm) |
| Hitch Lift Capacity (Category 3/3N) |
| Base |
4559 kg (10,050 lb) |
| High Capacity |
6350 kg (14,000 lb) |
| ELECTRICAL SYSTEM |
| Type |
12 volt, negative ground |
| Alternator |
200 amp |
| Batteries (Group 31) |
Two, 12 volt in parallel |
| Cold Cranking Amps |
925 each battery |
| Capacity (approximate minutes) |
190 |
| Terminals and outlets |
Battery boost, seven-terminal electrical outlet socket, GreenStar ready |
| BRAKES |
| Type |
Hydraulically operated wet disk, rear. Optional, front |
| TRANSMISSION |
| PowrQuad Plus |
| Type |
Electro-hydraulic speed shifting, traction clutch |
| Shifting |
Mechanical-hydraulic, single lever full power shift on-the-go, and under load in each range, left-hand reverser |
| Gear Selection |
30K, 16 forward/16 reverse speeds
40K, 20 forward/20 reverse speeds |
| AutoQuad Plus |
| Type |
Electro-hydraulic speed shifting, AUTO/ECO mode switch and FieldCruise |
| Shifting |
Mechanical-hydraulic, single lever full power shift on-the-go, and under load in each range, left-hand reverser |
| Gear Selection |
40K, 20 forward/20 reverse speeds
50K, 20 forward/20 reverse speeds |
| IVT |
| Type |
Hydro-mechanical, hydrostatic module, wet disk clutches and brakes |
| Shifting |
Automatic shifting under load, left-hand reverser or right-hand reverser |
| Gear Selection |
40K or 50K, Infinitely variable speed |
|
|
OU1092A,00003D3 -19-01MAY07-3/4
|
| |
7630 |
7730 |
7830 |
7930 |
| POWER TAKE OFF (PTO) |
| Type |
Fully independent, Type 1 or 2 shiftable two or three speed |
Fully independent, Type 3 single or shiftable two speed (kit) |
| Speed-540/1000 rpm |
1950 engine rpm |
| Speed-540E/1000E |
1750 engine rpm |
- |
- |
| Size |
35 mm (1-3/8 in.) |
35 mm (1-3/8 in. ) or 45 mm (1-3/4 in.) |
45 mm (1-3/4 in.) |
45 mm (1-3/4 in.) |
| Clutch |
Multiple wet-disk hydraulically operated |
| WEIGHT (Average Shipping) |
|
| 2WD Axle, PowrQuad Plus or AutoQuad Plus, and 480/80R42 (Rear) and 11.00-16 in. (Front) Size Tires |
6967 kg (15,360 lb) |
7194 kg (15,860 lb) |
- |
- |
| MFWD Axle, PowrQuad Plus or AutoQuad Plus, and 420/85R28 (Front) and 480/80R42 (Rear) Size Tires |
7484 kg (16,502 lb) |
7756 kg (17,102 lb) |
- |
- |
| MFWD Axle, IVT, and 420/90R30 (Front) and 480/80R46 (Rear) Size Tires |
7770 kg (17,131 lb) |
8042 kg (17,731 lb) |
8042 kg (17,731 lb) |
8042 kg (17,731 lb) |
|
|
OU1092A,00003D3 -19-01MAY07-4/4
|
|