| Item |
Daily or
10 Hours |
250 Hours |
750 Hours |
| Check Engine Oil |
· |
|
|
| Check Coolant Levels |
· |
|
|
| Drain Water Separator |
· |
|
|
| Check Transmission/Axle and Hydraulic Oil Levels |
· |
|
|
| Lubricate Hinge Pins |
· |
|
|
| Lubricate Steering Pins-If Equipped |
· |
|
|
| Inspect Drawbar Support (Tighten Cap Screws-If Needed) |
· |
· |
|
| Inspect Tires |
· |
|
|
| Check Hydraulic Accumulator |
· |
|
|
| Tighten Wheel and Weight Bolts-Initial at 100 Hours * |
· |
· |
|
| Change Engine Oil and Filter * |
|
· |
|
| Replace Primary and Secondary Fuel Filters-Initial at 100 Hours *** |
|
· |
|
| Service Batteries |
|
· |
|
| Clean Dual Beam Radar Sensor |
|
· |
|
| Drain Fuel Tank Sump |
|
· |
|
| Check Manual Brakes |
|
· |
|
| Check Neutral Start System |
|
· |
|
| Check PARK System |
|
· |
|
| Inspect Air Intake System for Loose Clamps |
|
· |
|
| Clean Cab Air and Recirculation Filters ** |
|
· |
|
| Lubricate Telescoping Drive Shafts |
|
· |
|
| Lubricate Lower Drive Line Bearing |
|
· |
|
| Lubricate Heavy-Duty Gudgeon Bearings |
|
· |
|
| Check Scraper Drawbar Bolts |
|
· |
|
| Replace Hydraulic Filter *** |
|
|
· |
| Clean Reservoir Screen-Initial at 100 Hours *** |
|
|
· |
| Replace Reservoir Breather Filter ** |
|
|
· |
| Replace Transmission/Axle Filter *** |
|
|
· |
| Test Coolant and Add Coolant Extender |
|
|
· |
| Clean Fuel Tank Vent Filter ** |
|
|
· |
* INITIAL oil and filter change is 100 hours maximum of operation. SCHEDULED interval (250 hours) can be extended to 375 hours if PLUS-50 oil and a John Deere Filter are used
** Interval can vary according to operating conditions
*** INITIAL filter change is 100 hours maximum of operation. |