| Item |
Annually |
1500 Hours |
2000 Hours |
4500 Hours |
| Cleaning or Replacing Primary and Secondary Engine Air Filters ** |
· |
|
|
|
| Servicing Batteries **** |
· |
|
|
|
| Checking Auxiliary Drive Belt |
· |
|
|
|
| Checking Seat Belts |
· |
|
|
|
| Replacing Cab Air Filters ** |
· |
|
|
|
| Checking Independent Link Suspension Upper and Lower Rod and Head End Accumulator Charge Pressure * |
· |
|
|
|
| Draining Clean Oil Reservoir |
|
· |
|
|
| Changing Transmission/Hydraulic Oil And Cleaning Transmission Filter Screen |
|
· |
|
|
| Cleaning Transmission Filter Screen (IVT Only) |
|
· |
|
|
| Replacing Transmission/Hydraulic Filters (Both Filters) |
|
· |
|
|
| Cleaning Hydraulic Oil Suction Screen |
|
· |
|
|
| Cleaning and Repacking Front Wheel Bearings (two-wheel drive only) |
|
· |
|
|
| Changing MFWD Differential Case Oil |
|
· |
|
|
| Lubricating Independent Link Suspension Axle Internal Tie Rod Ball Joints* |
|
· |
|
|
| Changing MFWD Or Independent Link Suspension Wheel Hub Oil |
|
· |
|
|
| Replacing SCV Stack Filter |
|
· |
|
|
| Replacing Front Hitch SCV Filter |
|
· |
|
|
| Lubricating Draft Link Support Shaft Bushing |
|
· |
|
|
| Adjusting Engine Valve Clearance * |
|
|
· |
|
| Draining, Flushing, and Refilling Engine Cooling System *** |
|
|
· |
|
| Replacing Engine Crankshaft Damper * |
|
|
|
· |
| * See your John Deere Dealer for questions |
| ** Interval can vary according to operating conditions |
| *** INITIAL change interval is 6 years or 6000 hours, provided cooling system is topped off using only John Deere Cool-GARD II and premix and coolant is tested at recommended intervals. After initial service, the SCHEDULED interval (2 years or 2000 hours) can be extended up to 6 years or 6000 hours depending on coolant used and if coolant is tested at recommended intervals (Reference "Drain Intervals for Diesel Engine Coolant" in Fuels, Lubricants and Coolant section of Operator Manual).COOL-GARD™ |
| **** For replacement batteries, follow manufacturer's recommendations. |