Application Fault List

SPN.FMI LAMP DTC CORRECTIVE ACTION
94.3 WARNING FUEL DELIVERY PRESSURE VOLTAGE OUT OF RANGE HIGH SEE YOUR SERVICING DEALER
94.4 WARNING FUEL DELIVERY PRESSURE VOLTAGE OUT OF RANGE LOW SEE YOUR SERVICING DEALER
94.17 WARNING FUEL DELIVERY PRESSURE LOW CHECK FUEL SUPPLY AND PRIME SYSTEM
97.3 WARNING WATER IN FUEL INDICATOR VOLTAGE OUT OF RANGE HIGH SEE YOUR SERVICING DEALER
97.4 WARNING WATER IN FUEL INDICATOR VOLTAGE OUT OF RANGE LOW SEE YOUR SERVICING DEALER
97.16 STOP WATER IN FUEL DETECTED STOP AND DRAIN WATER SEPARATOR
100.1 STOP ENGINE OIL PRESSURE LOW CHECK OIL LEVEL
100.4 WARNING ENGINE OIL PRESSURE VOLTAGE BELOW NORMAL OR SHORT LOW SOURCE SEE YOUR SERVICING DEALER
100.18 WARNING ENGINE OIL PRESSURE LOW CHECK OIL LEVEL
100.31 WARNING OIL PRESSURE DETECTED WITH ZERO ENGINE SPEED SEE YOUR SERVICING DEALER
102.2 WARNING BOOST PRESSURE SENSOR IN RANGE FAILURE SEE YOUR SERVICING DEALER
102.3 WARNING BOOST PRESSURE VOLTAGE OUT OF RANGE - HIGH SEE YOUR SERVICING DEALER
102.4 WARNING BOOST PRESSURE VOLTAGE OUT OF RANGE - LOW SEE YOUR SERVICING DEALER
103.0 WARNING TURBOCHARGER SPEED HIGH - MOST SEVERE SEE YOUR SERVICING DEALER
103.5 WARNING TURBOCHARGER SPEED FAULT SEE YOUR SERVICING DEALER
103.8 WARNING TURBOCHARGER SPEED FAULT CHECK TURBO AND WIRING
103.31 WARNING TURBOCHARGER SPEED DATA MISSING CHECK TURBO AND WIRING
105.0 STOP INTAKE MANIFOLD 1 AIR TEMPERATURE HIGH CHECK AIR CLEANER AFTER COOLER OR ROOM TEMP
105.3 WARNING INTAKE MANIFOLD1 TEMPERATURE VOLT ABOVE NORMAL OR SHORT HIGH SOURCE SEE YOUR SERVICING DEALER
105.4 WARNING INTAKE MANIFOLD1 TEMPERATURE VOLT BELOW NORMAL OR SHORT LOW SOURCE SEE YOUR SERVICING DEALER
105.15 WARNING MANIFOLD AIR TEMPERATURE HIGH - LEAST SEVERE SEE YOUR SERVICING DEALER
105.16 WARNING INTAKE MANIFOLD AIR TEMPERATURE HIGH CHECK AIR CLEANER AFTER COOLER OR ROOM TEMPERATURE
108.2 WARNING BAROMETRIC AIR PRESSURE SENSOR SIGNAL INVALID SEE YOUR SERVICING DEALER
110.0 STOP ENGINE COOL TEMPERATURE HIGH CHECK COOLING SYSTEM, REDUCE POWER

 

GB52027,0000B0F -19-28APR09-1/5

SPN.FMI LAMP DTC CORRECTIVE ACTION
110.3 WARNING ENGINE COOL TEMPERATURE VOLTAGE ABOVE NORMAL OR SHORT HIGH SOURCE SEE YOUR SERVICING DEALER
110.4 WARNING ENGINE COOL TEMPERATURE VOLTAGE BELOW NORMAL OR SHORT LOW SOURCE SEE YOUR SERVICING DEALER
110.15 WARNING ENGINE COOLANT TEMPERATURE HIGH CHECK COOLING SYSTEM REDUCE POWER
110.16 WARNING ENGINE COOLANT TEMPERATURE HIGH CHECK COOLING SYSTEM, REDUCE POWER
110.17 WARNING ENGINE COOLANT TEMPERATURE LOW-LEAST SEVERE CHECK COOLANT SYSTEM, SENSOR AND WIRING
157.3 STOP FUEL RAIL PRESSURE VOLTAGE OUT OF RANGE HIGH SEE YOUR SERVICING DEALER
157.4 STOP FUEL RAIL PRESSURE VOLTAGE OUT OF RANGE LOW SEE YOUR SERVICING DEALER
157.10 WARNING FUEL RAIL PRESSURE DROPPING TOO FAST CHECK FOR LEAKS
157.17 WARNING FUEL DELIVERY PRESSURE LOW CHECK FUEL SUPPLY AND PRIME SYSTEM
158.17 WARNING KEY SWITCH CIRCUIT PROBLEM CHECK SERVICE MANUAL
174.00 STOP FUEL TEMPERATURE HIGH ADD FUEL OR SWITCH FUEL TANKS
174.3 WARNING FUEL TEMPERATURE VOLTAGE ABOVE NORMAL OR SHORT HIGH SOURCE CHECK SENSOR AND WIRING
174.4 WARNING FUEL TEMPERATURE VOLTAGE BELOW NORMAL OR SHORT LOW SOURCE SEE YOUR SERVICING DEALER
174.16 WARNING FUEL TEMPERATURE HIGH ADD FUEL OR SWITCH FUEL TANKS
189.0 STOP ENGINE SPEED DERATE CONDITION EXISTS DUE TO FAULT CHECK FAULT CODES
412.0 STOP EGR TEMPERATURE INPUT VOLTAGE HIGH - MOST SEVERE HIGH LOADS OR POOR EGR COOLING
412.3 WARNING EGR TEMPERATURE VOLTAGE OUT OF RANGE - HIGH SEE YOUR SERVICING DEALER
412.4 WARNING EGR TEMPERATURE VOLTAGE OUT OF RANGE - LOW SEE YOUR SERVICING DEALER
412.15 WARNING EGR TEMPERATURE - LEAST SEVERE HIGH LOADS OR POOR EGR COOLING
412.16 WARNING EGR TEMPERATURE - MODERATELY SEVERE HIGH LOADS OR POOR EGR COOLING
611.3 STOP INJECTOR WIRING SHORTED TO BATTERY SEE YOUR SERVICING DEALER
611.4 STOP INJECTOR WIRING SHORTED TO GROUND SEE YOUR SERVICING DEALER
627.1 WARNING POWER SUPPLY LOW VOLTAGE TO INJECTORS SEE YOUR SERVICING DEALER
629.12 STOP ECU PROGRAMMING ERROR SEE YOUR SERVICING DEALER
629.13 STOP ECU FAILURE SEE YOUR SERVICING DEALER
636.2 WARNING ENGINE POS SENSOR TIMING SIGNAL ERROR SEE YOUR SERVICING DEALER
636.5 WARNING CAM POSITION SENSOR CURRENT LOW OR OPEN CIRCUIT SEE YOUR SERVICING DEALER

 

GB52027,0000B0F -19-28APR09-2/5

SPN.FMI LAMP DTC CORRECTIVE ACTION
636.6 WARNING CAM POSITION SENSOR CURRENT HIGH OR GROUNDED CIRCUIT SEE YOUR SERVICING DEALER
636.8 WARNING ENGINE POSITION SENSOR TIMING SIGNAL ERROR SEE YOUR SERVICING DEALER
636.10 WARNING ENGINE POSITION SENSOR TIMING SIGNAL ERROR SEE YOUR SERVICING DEALER
637.2 WARNING CRANK SENSOR TIMING SIGNAL ERROR SEE YOUR SERVICING DEALER
637.5 WARNING CRANK POSITION SENSOR CURRENT LOW OR OPEN CIRCUIT SEE YOUR SERVICING DEALER
637.6 WARNING TIMING SENSOR CURRENT BELOW NORMAL OR OPEN CIRCUIT SEE YOUR SERVICING DEALER
637.7 WARNING TIMING SENSOR/ENGINE POSITION SENSOR MISMATCH SEE YOUR SERVICING DEALER
637.8 WARNING TIMING SENSOR SIGNAL MISSING SEE YOUR SERVICING DEALER
637.10 WARNING TIMING SENSOR PATTERN ERROR DETECTED SEE YOUR SERVICING DEALER
641.04 WARNING VGT ACTUATOR DISABLED SEE YOUR SERVICING DEALER
641.12 WARNING VGT ACTUATOR BAD INTELLIGENT DEVICE OR COMPONENT CHECK TURBO WIRING AND GROUND
641.13 WARNING VGT LEARN ERROR CLEAR OLD TURBO LEARN VALUES
641.16 WARNING VGT TEMPERATURE HIGH - MODERATELY SEVERE LEVEL CHECK INTAKE AIR SYSTEM AND EGR
65X.2 STOP INJECTOR #X PART NUMBER IS INVALID SEE YOUR SERVICING DEALER
65X.5 WARNING CURRENT TO INJECTOR IN CYLINDER #X IS LESS THEN EXPECTED SEE YOUR SERVICING DEALER
65X.6 WARNING CURRENT TO INJECTOR IN CYLINDER #X INCREASES TOO RAPIDLY SEE YOUR SERVICING DEALER
65X.7 WARNING INJECTOR FUEL FLOW AT CYLINDER #X IS LOWER THAN EXPECTED SEE YOUR SERVICING DEALER
65X.13 WARNING INJECTOR #X QR CODE STRING ERROR SEE YOUR SERVICING DEALER
1075.12 WARNING LOW PRESSURE FUEL PUMP ERROR DETECTED SEE YOUR SERVICING DEALER
1136.0 STOP ECU TEMPERATURE HIGH - MOST SEVERE CHECK AIRFLOW AROUND ECU
1136.16 WARNING ECU TEMPERATURE HIGH - MODERATELY SEVERE CHECK AIRFLOW AROUND ECU
1172.3 WARNING COMPRESSOR INLET TEMPERATURE INPUT VOLTAGE OUT OF RANGE - HIGH SEE YOUR SERVICING DEALER
1172.4 WARNING COMPRESSOR INLET TEMPERATURE INPUT VOLTAGE OUT OF RANGE - LOW SEE YOUR SERVICING DEALER
1180.0 STOP TURBINE INLET TEMPERATURE HIGH - MOST SEVERE FUEL TO AIR RATIO IS TO HIGH
1180.16 WARNING TURBINE INLET TEMPERATURE HIGH - MODERATELY SEVERE FUEL TO AIR RATIO IS TO HIGH

 

GB52027,0000B0F -19-28APR09-3/5

SPN.FMI LAMP DTC CORRECTIVE ACTION
1347.03 STOP FUEL PUMP ASSEMBLY 1 SENSOR VOLTAGE OOR HIGH SEE YOUR SERVICING DEALER
1347.5 STOP FUEL PUMP ASSEMBLY 1 CIRCUIT OPEN, SHORTED GROUND OR OVERLOAD SEE YOUR SERVICING DEALER
1347.7 WARNING FUEL PUMP ASSEMBLY 1 RAIL PRESSURE CONTROL MISMATCH CHECK FUEL FILTER, LINES AND HIGH PRESSURE PUMP
1569.31 WARNING ENGINE PROTECTION TORQUE FUEL DERATE LIMIT CONDITION EXIST CHECK FAULT CODES
2630.0 STOP CHARGE AIR COOLER TEMPERATURE HIGH - MOST SEVERE CHECK AIR COOLER, RADIATOR AND FRESH AIR SENSOR
2630.3 WARNING CHARGE AIR COOLER TEMPERATURE OUT OF RANGE HIGH SEE YOUR SERVICING DEALER
2630.4 WARNING CHARGE AIR COOLER TEMPERATURE OUT OF RANGE LOW SEE YOUR SERVICING DEALER
2630.15 WARNING CHARGE AIR COOLER TEMPERATURE HIGH-LEAST SEVERE CHECK AIR COOLER, RADIATOR AND FRESH AIR SENSOR
2630.16 WARNING CHARGE AIR COOLER TEMPERATURE HIGH-MODERATELY SEVERE CHECK AIR COOLER, RADIATOR AND FRESH AIR SENSOR
2659.2 WARNING CHARGE AIR COOLER FLOW/TEMPERATURE MISMATCH SEE YOUR SERVICING DEALER
2659.15 WARNING CHARGE AIR COOLER FLOW RATE ABOVE NORMAL SEE YOUR SERVICING DEALER
2659.17 WARNING CHARGE AIR COOLER FLOW RATE BELOW NORMAL CHECK FOR CLOGGED INTERCOOLER AND EGR VALVE AND WIRING
2790.16 WARNING TURBOCHARGER COMPRESSOR OUTLET TEMPERATURE HIGH-MOST SEVERE CHECK FOR CLOGGED INTERCOOLER OR HIGH AMBIENT TEMPERATURE
2791.2 WARNING EGR VALVE SENSOR VOLTAGE MISMATCH CHECK EGR VALVES AND RUN HARNESS DIAGNOSTICS
2791.3 WARNING EGR VALVE SENSOR VOLTAGE OUT OF RANGE HIGH CHECK EGR VALVE AND WIRING
2791.4 WARNING EGR VALVE SENSOR VOLTAGE OUT OF RANGE LOW CHECK EGR VALVE AND WIRING
2791.7 WARNING EGR VALVE NOT RESPONDING OR OUT OF ADJUSTMENT CHECK EGR VALVE AND CLEAR STOPS
2791.13 WARNING EGR VALVE OUT OF CALIBRATION CHECK EGR VALVE AND CLEAR STOPS
2791.31 WARNING EGR VALVE POSITION INVALID CHECK EGR VALVE AND CLEAR STOPS
2795.7 WARNING VGT ACTUATOR NOT RESPONDING OR OUT OF ADJUSTMENT SEE YOUR SERVICING DEALER
3509.3 STOP SENSOR VOLTAGE 1 (+5 VDC) ABOVE NORMAL OR SHORT HIGH SEE YOUR SERVICING DEALER
3509.4 STOP SENSOR VOLTAGE 1 (+5 VDC) BELOW NORMAL OR SHORT LOW SEE YOUR SERVICING DEALER
3510.3 WARNING SENSOR VOLTAGE 2 (+5 VDC) ABOVE NORMAL OR SHORT HIGH SEE YOUR SERVICING DEALER
3510.4 WARNING SENSOR VOLTAGE 2 (+5 VDC) BELOW NORMAL OR SHORT LOW SEE YOUR SERVICING DEALER

 

GB52027,0000B0F -19-28APR09-4/5

SPN.FMI LAMP DTC CORRECTIVE ACTION
3511.3 WARNING SENSOR VOLTAGE 3 (+5 VDC) ABOVE NORMAL OR SHORT HIGH SEE YOUR SERVICING DEALER
3511.4 WARNING SENSOR VOLTAGE 3 (+5 VDC) BELOW NORMAL OR SHORT LOW SEE YOUR SERVICING DEALER
3512.3 WARNING SENSOR VOLTAGE 4 (+5 VDC) ABOVE NORMAL OR SHORT HIGH SEE YOUR SERVICING DEALER
3512.4 WARNING SENSOR VOLTAGE 4 (+5 VDC) BELOW NORMAL OR SHORT LOW SEE YOUR SERVICING DEALER
3513.3 WARNING SENSOR VOLTAGE 5 (+5 VDC) ABOVE NORMAL OR SHORT HIGH SEE YOUR SERVICING DEALER
3513.4 WARNING SENSOR VOLTAGE 5 (+5 VDC) BELOW NORMAL OR SHORT LOW SEE YOUR SERVICING DEALER

 

GB52027,0000B0F -19-28APR09-5/5