Service Interval Chart—Annual, 1500 Hour, 2000 Hour, 3000 Hour, 4500 Hour, 5000 Hour and 6000 Hour

Item

Annual

1500 Hours

2000 Hours

3000 Hours

4500 Hours

5000 Hours

6000 Hours

Change Engine Oil and Filter1

•

            

Service Batteries2 and Connections

•

            

Test Coolant Freeze Point3

•

            

Inspect Seat Belts

•

            

Replace Primary and Secondary Engine Air Filters3

•

            

Replace Cab Air and Recirculation Filters4

•

            

Check HydraCushion™ Accumulator Charge Pressure (If Equipped)45

•

•

          

Change Transmission, Hydraulic and Axle Oil and Filters

  

•

          

Clean Aftertreatment Fuel Injector (15.0 L Engine)5

 

•

          

Replace radiator pressure cap (15.0 L Engine)

  

•

          

Clean Hydraulic Oil Sump Screen

  

•

          

Inspect Fan Belt Tensioner (15.0 L Engine only)

  

•

          

Lubricate Draft Link Support Shaft Bushing

  

•

          

Check Axle End Play5

 

•

          

Replace Fuel Tank Vent Filters6

 

•

          

Replace Diesel Exhaust Fluid (DEF) Tank Filter (FT4/Stage IV Engines Only)7,8

 

•

    

•

    

Adjust Engine Valve Clearance5 (T2/Stage II Engines Only)7

   

•

        

Change Crankcase Breather Filter Element (15L Engine Only)

     

•

      

Adjust Engine Valve Clearance9 (9.0, 13.5 and 15.0 L FT4/Stage IV Engines Only)7

     

•

      

Replace Transmission Drive Shaft Damper10

     

•

•

    

Replace Diesel Exhaust Fluid (DEF) Dosing Unit Filter (FT4/Stage IV Engines only)7

       

•

    

Replace Crankshaft Damper (9.0 and 13.5 L Tier II/Stage II Engines Only)11

         

•

  

Drain, Flush, and Refill Engine Cooling System12 and Replace Engine Coolant Thermostats

            

•

HydraCushion is a trademark of Deere & Company
1 Perform service at least once per year. Perform oil change in accordance with Engine Oil and Filter Service Intervals in Fuel, Lubricants and Coolant section of this Operator’s Manual.
2 For replacement batteries, follow manufacturer’s recommendations.
3 Perform service every 1000 hours or annually - whichever comes first.
4 Perform service every 1500 hours or annually - whichever comes first.
5 See your John Deere™ dealer.
6 Interval may vary according to operating conditions.
7 To confirm which engine your tractor is equipped with, see Record Engine Serial Number in Identification Numbers section of this Operator’s Manual.
8 Replace after initial 1500 hours, then 3 years or 4500 hours thereafter.
9 See your John Deere™ dealer.
10 Normal duty operation replace at 4500 hours. If operating in heavy duty situations, replace every 3000 hours.
11 See your John Deere dealer.
12 INITIAL change interval is 6 years or 6000 hours, provided cooling system is topped off using only John Deere Cool-GARD™ II and premix and coolant is tested at recommended intervals. SCHEDULED interval (2 years or 2000 hours) can be extended up to 6 years or 6000 hours depending on coolant used and if coolant is tested at recommended intervals. See Drain Intervals for Diesel Engine Coolant in Fuel, Lubricants and Coolant section of this Operator’s Manual.

RX32825,0000628-19-20140730