Service Interval Chart—Annual, 1500 Hours, 2000 Hours, 3000 Hours, 4500 Hours, 5000 Hours and 6000 Hours

Item

Annual

1500 Hours

2000 Hours

3000 Hours

4500 Hours

5000 Hours

6000 Hours

Change Engine Oil and Filter1

•

            

Service Batteries2 and Connections

•

            

Test Coolant Freeze Point3

•

            

Inspect Seat Belts

•

            

Replace Cab Fresh Air and Recirculation Filters3

•

            

Check TLS™ Plus Accumulator Charge Pressure (If Equipped)4

•

            

Check Cab Suspension Accumulator Charge Pressure (If Equipped)5

•

            

Inspect Primary and Secondary Engine Air Filters6

•

            

Inspect Fan Belt and Fan Belt Tensioner

 

•

          

Change MFWD or TLS™ Plus Axle Housing Oil

  

•

          

Change MFWD or TLS™ Plus Wheel Hub Oil

  

•

          

Lubricate Draft Link Support Shaft Bushing

  

•

          

Change Front PTO Housing Oil and Filter (If Equipped)7

 

•

          

Change Transmission, Hydraulic and Axle Oil and Filters

  

•

          

Clean Hydraulic System Sump Screen

  

•

          

Replace Open Crankcase Ventilation Filter (6.8 L Engines)8

 

•

          

Replace Trailer Air Brake Dryer Filter (If Equipped)9

 

•

          

Replace Fuel Tank Vent Filter10

 

•

          

Adjust Engine Valve Clearance (T2/Stage II Engines)8,4

   

•

        

Adjust Engine Valve Clearance (FT4/Stage IV Engines)8,4

     

•

      

Replace Diesel Exhaust Fluid (DEF) Dosing Unit Filter (FT4/Stage IV Engines)8,11

       

•

    

Replace Diesel Exhaust Fluid (DEF) Tank Filter (FT4/Stage IV Engines)8,12

 

•

    

•

    

Replace Transmission Drive Shaft Damper4

       

•

    

Replace Engine Crankshaft Damper4

         

•

  

Drain, Flush, and Refill Engine Cooling System and Replace Cooling System Thermostats and De-aeration Tank Cap13

           

•

TLS is a trademark of Deere & Company
1 Perform service at least once per year. Perform oil change in accordance with Engine Oil and Filter Service Intervals in Fuel, Lubricants and Coolant section of this Operator's Manual.
2 For replacement batteries, follow manufacturer’s recommendations.
3 Perform service every 1000 hours or annually - whichever comes first.
4 See your John Deere™ dealer.
5 Perform service every 1000 hours or annually - whichever comes first. See your John Deere™ dealer.
6 Interval may vary, according to operating conditions.
7 Normal service interval is 1500 hours. However, change oil and filter after first 100 hours of tractor operation.
8 To confirm which engine your tractor is equipped with, see Record Engine Serial Number in Identification Numbers section of this Operator’s Manual.
9 Replace every TWO years or 1500 hours, whichever comes first.
10 Interval may vary according to operating conditions.
11 Replace every THREE years or 4500 hours, whichever comes first.
12 Replace after one year, then every 4500 hours.
13 INITIAL change interval is 6 years or 6000 hours, provided cooling system is topped off using only John Deere™ Cool-GARD™ II and premix and coolant is tested at recommended intervals. SCHEDULED interval (2 years or 2000 hours) can be extended up to 6 years or 6000 hours depending on coolant used and if coolant is tested at recommended intervals. See Drain Intervals for Diesel Engine Coolant in Fuel, Lubricants and Coolant section of this Operator’s Manual.

TO84419,0000074-19-20140818