|
Perform the following steps to place tractor into storage:
IMPORTANT:
Any time tractor will not be used for several months, use this procedure to minimize corrosion and deterioration. Use an AR41785 Engine Storage Kit and an extra 0.95 L (1 pt) of AR41870 Corrosion Inhibitor.
NOTE:
Whenever possible store tractor in a building or under a roof to avoid damage resulting from prolonged exposure to the elements.
1.
Service air cleaner. (See "Service Air Cleaner Elements"-5085M, 5095M, 5095MH and 5105M" in section 50 and/or "Replace Air Cleaner Elements"-5065M and 5075M" in section 45 of Maintenance Guide.)
2.
Change engine oil and filter. (See "Change Engine Oil and Filter" in section 40 of Maintenance Guide.)
3.
If coolant has been in tractor for two years, flush cooling system. (See your John Deere dealer.) Add 50 percent antifreeze water mixture. Test coolant for adequate cold weather protection.
4.
Add 0.5 L (16 oz) inhibitor to engine crankcase at filler.
5.
Add 0.25 L (9 oz) of corrosion inhibitor to transmission-hydraulic system fill port.
6.
Drain fuel and add back 4 L (1 gal) of fuel. Then add 0.4 L (12 oz) of corrosion inhibitor.
7.
Add 0.5 L (16 oz) more inhibitor to fuel tank at filler/cap.
|
8.
Depress clutch and start engine. Run engine until it reaches operating temperature. Also raise and lower 3-point hitch several times. Shut off engine.
9.
Remove air intake hose at manifold. Pour 0.1 L (3 oz) inhibitor into manifold and replace hose. Pull hand throttle back to slow idle position. Crank engine only a few revolutions.
10.
For 5085M, 5095M and 5095MH Tractors:
Disconnect fuel shut-off solenoid wiring lead/connector. (This will prevent engine from starting while cranking.)
11.
Release tension on auxiliary drive belts. Remove belt from air conditioner pulley and fan pulley.
12.
Remove and clean battery. Store in a cool, dry place. Keep battery charged.
1
13.
Coat exposed metal surfaces, such as adjustable front axles, if extended, with grease or a corrosion inhibitor.
14.
Seal air inlets, exhaust, crankcase fill cap, fuel tank cap, radiator overflow hose, and transmission and hydraulic system fill cap using plastic bags and tape.
15.
Protect tires from heat and sunlight:
-
Raise tires off the ground (move tractor once a month if tires are not raised off the ground).
-
Cover wheels with water-proof tarpaulin.
-
Avoid storing at temperatures greater than 29° C (85° F).
-
Avoid direct sunlight.
16.
Thoroughly clean tractor. Touch up any painted surfaces that are scratched or chipped.
|