|
Nothing Works
|
Battery disconnect switch is off.
|
Turn switch on.
|
|
|
Battery undercharged or dead.
|
See your authorized dealer.
|
|
|
Battery cables making poor connections.
|
Clean cable connections at battery and starter solenoid.
|
|
Starter Will Not Crank Engine
|
Battery disconnect switch off.
|
Turn switch on.
|
|
|
Battery undercharged or dead.
|
See your authorized dealer.
|
|
|
Battery cables making poor connection.
|
Clean connections at battery, starter, and ground to frame.
|
|
|
Starter relay.
|
See your authorized dealer.
|
|
|
Starter solenoid.
|
See your authorized dealer.
|
|
|
Starter motor.
|
See your authorized dealer.
|
|
|
Starter motor pinion "jammed" in flywheel gear.
|
See your authorized dealer.
|
|
|
Major engine malfunction.
|
See your authorized dealer.
|
|
|
Key switch.
|
See your authorized dealer.
|
|
|
Wrong oil.
|
Change oil.
|
|
Engine Cranks Slowly
|
Battery undercharged.
|
See your authorized dealer.
|
|
|
Starter armature bearings worn causing starter "drag".
|
See your authorized dealer.
|
|
|
Battery cable connections loose or corroded.
|
Clean and/or tighten connections.
|
|
Starting Motor Turns, But Engine Will Not Crank
|
Starter pinion not engaging flywheel gear.
|
See your authorized dealer.
|
|
|
Starter pinion or flywheel gear teeth broken.
|
See your authorized dealer.
|
| Symptom |
Problem |
Solution |
|
Starter Motor Continues To Run After Engine Starts
|
Starter solenoid stuck.
|
Lightly tap on case of solenoid. Replace solenoid.
|
|
|
Starter not disengaging.
|
Lightly tap on starter case. Replace or repair starter "shift" mechanism.
|
|
|
Start relay stuck.
|
Lightly tap on relay. Replace relay.
|
|
|
Key switch.
|
See your authorized dealer.
|
|
|
Wiring harness shorted.
|
See your authorized dealer.
|
|
Low Battery Output
|
Dirty or wet battery top, causing discharge.
|
Clean battery and wipe dry.
|
|
|
Corroded or loose battery cable ends.
|
Clean and tighten cable end clamps. Recharge battery. If unit has two batteries, recharge separately.
|
|
|
Broken or loose battery posts.
|
Wiggle posts by hand. If posts are loose or will turn, replace battery. If unit has two batteries, replace both batteries.
|
|
|
Loose fan/alternator belt, or worn pulley.
|
Inspect belt or pulley. Adjust or replace as necessary.
|
|
Starter Solenoid Chatters
|
Poor connections at battery or starter.
|
Clean connections.
|
|
|
Low battery charge.
|
Recharge or replace battery.
|
|
|
Starter solenoid "hold-in" windings open.
|
See your authorized dealer.
|
|
Engine Cranks But Does Not Start
|
Hydraulic shut-off valve turned off.
|
Turn on hydraulic shut-off valve.
|
|
|
Fuel shut-off solenoid.
|
See your authorized dealer.
|
|
|
Key switch.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
| Symptom |
Problem |
Solution |
|
Start Aid Does Not Work
|
Empty start aid can.
|
Replace start aid can.
|
|
|
Start aid switch.
|
See your authorized dealer.
|
|
|
Start aid solenoid.
|
See your authorized dealer.
|
|
Noisy Alternator
|
Worn drive belt.
|
Inspect and replace.
|
|
|
Pulley misaligned.
|
Adjust alternator mount.
|
|
|
Alternator bearing.
|
Loosen alternator belts. Turn pulley by hand. If any roughness is felt, repair alternator.
|
|
|
Internal alternator.
|
See your authorized dealer.
|
|
Alternator Indicator Light Shows Low Charge At Slow Idle
|
Loose or glazed alternator belt.
|
Check belt. Replace if glazed, tighten if loose.
|
|
|
Engine rpm low.
|
Raise engine rpm. If gauge reading remains low, see your authorized dealer.
|
|
|
Excessive electrical load from added accessories.
|
Remove accessories or install higher output alternator.
|
|
|
Loose or corroded electrical connections on battery, ground strap, starter, or alternator.
|
Inspect, clean, or tighten electrical connections.
|
|
|
Alternator.
|
See your authorized dealer.
|
|
Hour Meter Does Not Work
|
Key switch.
|
See your authorized dealer.
|
|
|
Hour Meter.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
|
Transmission Oil Temperature Gauge Does Not Work
|
Fuse.
|
Replace fuse.
|
|
|
Gauge.
|
See your authorized dealer.
|
|
|
Gauge sender.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
| Symptom |
Problem |
Solution |
|
Engine Oil Pressure Indicator Light Does Not Work
|
Fuse.
|
Replace fuse.
|
|
|
Bulb.
|
See your authorized dealer.
|
|
|
Gauge sender.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
|
Indicator Light In Dash Panel Is Inoperative
|
Bulb.
|
Replace bulb.
|
|
|
Sending unit for that function malfunctioning.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
|
Horn Inoperative
|
Fuse.
|
Replace fuse.
|
|
|
Horn.
|
See your authorized dealer.
|
|
|
Horn switch.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
|
Wiper Does Not Work
|
Wiper fuse.
|
Replace fuse.
|
|
|
Wiper switch.
|
See your authorized dealer.
|
|
|
Wiper motor.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
|
Heater/Air Conditioner Fan Does Not Work
|
Fuse.
|
Replace fuse.
|
|
|
Fan motor switch.
|
See your authorized dealer.
|
|
|
Fan motor resistor.
|
See your authorized dealer.
|
|
|
Fan motor.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
| Symptom |
Problem |
Solution |
|
Dome Light Does Not Work
|
Bulb.
|
Replace bulb.
|
|
|
Fuse.
|
Replace fuse.
|
|
|
Dome light switch.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
|
Air Conditioning System Does Not Operate
|
Condenser screen clogged.
|
Clean.
|
|
|
Accessory relay.
|
See your authorized dealer.
|
|
|
Fan motor switch.
|
See your authorized dealer.
|
|
|
Fan motor resistor.
|
See your authorized dealer.
|
|
|
Fan motor.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|
|
|
A/C temperature control switch.
|
See your authorized dealer.
|
|
|
A/C low pressure switch.
|
See your authorized dealer.
|
|
|
A/C high pressure switch.
|
See your authorized dealer.
|
|
|
A/C compressor clutch coil.
|
See your authorized dealer.
|
|
|
A/C circuit breaker.
|
See your authorized dealer.
|
|
|
Condenser fan motor.
|
See your authorized dealer.
|
|
|
Wiring harness.
|
See your authorized dealer.
|