|
Fuel Gauge Does Not Move, No indicator Lights, Machine Will Not Crank
|
Start relay fuse
|
Replace fuse.
|
|
|
Poor or loose red connector from relay
|
Push red connector together under loader control lever.
|
|
|
Poor or loose ground connection
|
Check ground screw under loader control lever.
|
|
Fuel Gauge Does Not Move, No Indicator Lights, But Machine Will Crank
|
Monitor/gauge fuse
|
Replace fuse.
|
|
|
Poor or loose ground connection
|
Check ground screw under loader control lever.
|
|
Engine Coolant Temperature Indicator Light Does Not Indicate Overheating or Bulb Does Not Light In BULB CHECK Position
|
Indicator light
|
Turn key switch to BULB CHECK. If no light, replace bulb.
|
|
|
Sender
|
Replace sender.
|
|
Engine Oil Pressure Indicator Will Not Light
|
Monitor/gauge fuse
|
Replace fuse.
|
|
|
Indicator light
|
Turn key switch to BULB CHECK. If no light, replace bulb.
|
|
|
Wire, connector or sender
|
Ground yellow wire at sender. Indicator must light. If not, repair wiring or replace sender.
|
|
Alternator Indicator Will Not Light
|
Monitor/gauge fuse
|
Replace fuse.
|
|
|
Indicator light
|
Turn key switch to BULB CHECK. If indicator does not light, replace bulb.
|
|
Monitor Lights Do Not Come On During BULB CHECK
|
Monitor/gauge fuse
|
Replace fuse.
|
|
|
Indicator light
|
Replace bulb.
|
| Symptom |
Problem |
Solution |
|
Fuel Gauge Shows Empty At All Times
|
Poor ground connections at gauge
|
Remove dash panel and check gauge mounting hardware.
|
|
|
Poor power connection at gauge
|
Remove dash panel and check gauge mounting hardware.
|
|
|
Hole in fuel sender float
|
Replace sender unit. Ground fuel sender. Gauge must indicate full. If it does not, the wiring is defective. Repair wiring. See your authorized dealer.
|
|
|
Gauge
|
Replace gauge.
|
|
Fuel Gauge Shows Full At All Times
|
Open circuit at sender or wire
|
Remove wire at sender. If gauge still indicates full, locate and repair short between sender and gauge.
|
|
|
Sender float stuck
|
Repair or replace sender. Remove sender wire. If gauge still indicates full, replace gauge.
|
|
Horn Does Not Sound
|
Horn ground
|
Ground horn to machine frame.
|
|
|
Horn fuse
|
Check and replace.
|
|
|
Horn
|
Replace horn.
|
|
|
Horn button
|
Replace horn button.
|
|
No Work or Driving Lights
|
Driving light fuse
|
Check and replace.
|
|
|
Poor ground
|
Inspect and tighten.
|
|
|
Burned out bulb
|
Replace with new bulb.
|
|
Rear Lights Do Not Operate
|
Loose connector in wiring harness of ROPS
|
Inspect and reconnect.
|
|
|
Poor ground at light
|
Inspect and tighten.
|
|
Dim Lights
|
Low battery charge
|
Check battery connections.
|
|
|
Low alternator output
|
Check belt tension and adjust.
|
|
|
Poor ground at lights
|
Clean and tighten.
|