9370R, 9420R, 9470R, 9520R, 9570R and 9620R
Tractors (Serial No. 015000-)(North American Edition) K4
Copyright 2014 © Deere & Company. THIS DATA IS THE PROPERTY OF DEERE & COMPANY. ALL USE AND/OR REPRODUCTION NOT SPECIFICALLY AUTHORIZED BY DEERE & COMPANY IS PROHIBITED.
All information, illustrations and specifications in this manual are based on the latest information available at the time of publication. The right is reserved to make changes at any time without notice.
Foreword
Trademarks
Quick Reference Specifications
Section 05 - Safety
Recognize Safety Information
Understand Signal Words
Follow Safety Instructions
Prepare for Emergencies
Wear Protective Clothing
Protect Against Noise
Handle Fuel Safely—Avoid Fires
Handle Starting Fluid Safely
Fire Prevention
In Case of Fire
Avoid Static Electricity Risk When Refueling
Keep ROPS Installed Properly
Use Foldable ROPS and Seat Belt Properly
Stay Clear of Rotating Drivelines
Use Steps and Handholds Correctly
Read Operator Manuals for ISOBUS Implements
Use Seat Belt Properly
Operating the Tractor Safely
Avoid Backover Accidents
Limited Use in Forestry Operation
Operating the Loader Tractor Safely
Keep Riders Off Machine
Instructional Seat
Use Safety Lights and Devices
Use a Safety Chain
Transport Towed Equipment at Safe Speeds
Use Caution On Slopes and Uneven Terrain
Freeing a Mired Machine
Avoid Contact with Agricultural Chemicals
Handle Agricultural Chemicals Safely
Handling Batteries Safely
Avoid Heating Near Pressurized Fluid Lines
Remove Paint Before Welding or Heating
Handle Electronic Components and Brackets Safely
Practice Safe Maintenance
Avoid Hot Exhaust
Clean Exhaust Filter Safely
Work In Ventilated Area
Support Machine Properly
Prevent Machine Runaway
Park Machine Safely
Transport Tractor Safely
Service Cooling System Safely
Service Accumulator Systems Safely
Service Tires Safely
Service Front-Wheel Drive Tractor Safely
Tightening Wheel Retaining Bolts/Nuts
Avoid High-Pressure Fluids
Do Not Open High-Pressure Fuel System
Store Attachments Safely
Dispose of Waste Properly
Section 10 - Safety Signs
Operator’s Manual
Seat Belt
Instructional Seat (If Equipped)
Starter
Engine Block Heater—9.0 L Engine
Engine Block Heater—13.5 L Engine
Engine Block Heater—15.0 L Engine
HydraCushion™ Suspension (If Equipped)
Hinge Area
Park Brake (Stored energy)
Rotating Driveline (If Equipped)
Rear PTO (If Equipped)
Quick Coupler (If Equipped)
Section 15 - Controls and Instruments
Front Console
Information Indicators
Aftertreatment Indicators Overview
Corner Post Display
Digital Indicators—Tachometer, Ground Speed and Transmission
Gauges—Coolant Temperature, Diesel Exhaust Fluid (DEF)
Level, and Fuel Level
CommandARM™ with Generation 4 CommandCenter™ Display
CommandARM™ Joystick (If Equipped)
CommandARM™ Hitch Controls
CommandARM™ SCV Controls
CommandARM™ Climate, Radio and Lighting Controls
CommandARM™ PTO Control Lever (If Equipped)
CommandARM™ Left-Hand Side Controls
CommandARM™ ISOBUS Shortcut Button (ISB)
External Switches (If Equipped)
Foot Decelerator
Section 16 - CommandCenter™
Onscreen Help
Generation 4 CommandCenter™ Display
Generation 4 CommandCenter™ Processor
Federal Communications Commission and Industry Canada Notification
Run Page Structure
Menu
Tractor Settings Overview
Operating System Applications Overview
AMS Applications Overview
Automation Status Overview
Navigate Generation 4 CommandCenter™
Turn Display On and Off
Clean CommandCenter™ Display
Navigate Run Pages on Main Page
Shortcut Buttons
Navigate to Display & Sound
Display & Sound
Brightness
Sound
Multiple Displays
Display Calibration
Navigate to Date & Time
Date & Time Application
Change Current Date
Change Current Time
Navigate to Language & Units
Language & Units
Language & Units Settings
Change Pages and Values
Status Center
Navigate to Software Manager
Software Manager
Factory and Service ADVISOR™ Installed Onscreen Help
Update Display Software
Activations
Service ADVISOR™ Remote
Vehicle Reprogramming
Troubleshooting - Reprogramming
Navigate to File Manager
File Manager
USB Drive
Capture Screen Shots
Navigate to Diagnostics Center
Diagnostics Center
Controller Diagnostics
Diagnostic Information
Hide Diagnostic Center
Diagnostic Trouble Codes
Readings
CAN Bus Information
CAN Bus Values
Network
Navigate to Users & Access
Users & Access
User Profiles
Access Groups
Navigate to Layout Manager
Layout Manager
Active Set
Shortcut Bar
All Run Pages
Add, Edit, or Duplicate Run Pages
Navigate to Fields
Fields
Manage Clients, Farms, and Fields
AutoTrac™ Guidance
Navigate to Machine Profile
Machine Profiles
Navigate to Implement Profile
Implement Profiles
Navigate to Machine Monitor
Machine Monitor
Navigate to Work Monitor
Work Monitor
Work Recording
Navigate to Maintenance & Calibrations
Maintenance & Calibrations
Calibrations
Service Intervals
Navigate to Controls Setup
Controls Setup
Controls
Automation Status
Read ISOBUS Controller’s Operator’s Manual
ISOBUS VT
StarFire™ GPS Receiver
Use Video Display Capability Properly
Installing Video Display Camera
Three-Camera Video Connectors with Ethernet Cable (If Equipped)
Navigate to Video Application
Video Application
Video Triggers
Section 17 - Operate the Radio
Using Premium Radio
Select Radio Receiver Wave Band
Federal Communications Commission (FCC) Bluetooth® Information
Mexico Bluetooth® Information
Turn Confirmation Beep On/Off (BEEP)
Adjust Maximum Volume at Power-On (ONVOL)
Program Type (PTY)
Treble Reduction During Interference (HCUT)
Set Key Function (KEY PRG)
SiriusXM® Radio, General Information
Display XM Serial Number
External Sources (Premium Radio)
Select Radio Source With Generation 4 CommandCenter™
AM, FM, Weather Channel Home Page
Premium Radio CD Home Page (If Equipped)
Premium Radio XM Home Page (If Equipped)
Premium Radio USB Home Page (If Equipped)
Premium Radio Bluetooth® Home Page (If Equipped)
Auxiliary Home Page
Operating Phone
Contact List
Recent Calls
Pairing Bluetooth® Device—On Generation 4 CommandCenter™
Section 20 - Lights
Light Identification
Configurable Lights
Steering Column Light Controls
Exit Lights
Operating Turn Signals and High/Low Beam
Safety Lights and Devices
CommandARM™ Light Buttons
Hazard Lights and Extremity Warning Lights
Rotary Beacon Light (If Equipped)
7-Pin Outlet
Section 25 - Operator Station
Avoid Contact with Agricultural Chemicals
Adjust ComfortCommand™ Seat
Adjust Heated Leather Seat (If Equipped)
Adjust ActiveSeat™ (If Equipped)
Operator Presence Sensor
Using Instructional Seat
Adjust CommandARM™ Position
Adjusting Steering Wheel and Column
Operating Horn
Generation 4 CommandCenter™ HVAC Settings
Operating Front Windshield Wiper and Washer
Operating Rear Wiper and Washer (If Equipped)
Operating Right-Hand Wiper and Washer (If Equipped)
Installing Business Band or CB Radio and Antenna
Using Auxiliary Power Strip and Electrical Outlets (If Equipped)
Connecting Compatible Electronic Equipment
Configuring Tractor for GPS/Radar
Mounting StarFire™ Receiver
Installing GreenStar™ System Components
Install Machine Communications Radio (MCR) Antenna (If Equipped)
Connect AutoTrac™ Assisted Steering System (If Equipped)
Machine Sync (If Equipped)
Monitor Bracket Mounts
Use Manual Mirror (If Equipped)
Use Electric Mirror (If Equipped)
Use Telescoping Heated Electric Mirror (If Equipped)
Pull-Down Sunshade (If Equipped)
Refrigerator or Storage Space (If Equipped)
Using Implement Connector
Section 30 - Operate the Engine
Exhaust Filter System Overview—Final Tier 4 and Stage
IV Engines
Selective Catalytic Reduction (SCR) System Overview
AUTO Exhaust Filter Cleaning Mode—Final Tier 4 and Stage
IV Engines
Parked Exhaust Filter Cleaning—Final Tier 4 and Stage
IV Engines
Selective Catalytic Reduction (SCR) System - Final Tier 4 and
Stage IV Engines
Engine Fuel System and Power Rating
Battery Disconnect Switch (If Equipped)
Starting the Engine
Running the Engine
Stopping the Engine
Reduce Fuel Consumption
Cold Weather Starting—With Starting Aid
Cold Weather Starting And Operation—Internal Starting
Aid
Changing Starting Fluid Can (If Equipped)
Low Fuel or Low Diesel Exhaust Fluid (DEF) Warning
Restarting Engine That Has Run Out of Fuel
Using Engine Coolant Heater—9.0 L (If Equipped)
Using Engine Coolant Heater—13.5 L Engine (If Equipped)
Using Engine Coolant Heater—15.0 L Engine (If Equipped)
Using a Battery Booster or Charger
Section 40 - Operate the Tractor
Avoid Contact with Agricultural Chemicals
Clean Vehicle of Hazardous Pesticides
Keep Riders Off Machine
Keep Operator Station Window and Door Closed
Use Seat Belts
Use Emergency Exit
Disconnect Battery - Final Tier 4 and Stage IV Engines
Change to Different Size of Tires
Warm-Up Transmission-Hydraulic System
Activate and Set FieldCruise™
Use FieldCruise™ with Different Transmission Modes
Operate HydraCushion™ Front Axle Suspension (If Equipped)
Differential Lock
Adjust Steering Angle to Disengage Differential Lock
Use Foot Decelerator
Drivetrain Protection—9470R, 9520R,
9570R and 9620R
Brake Use
Hydraulic Trailer Brakes (If Equipped)
Backup Alarm (If Equipped)
Come-Home Mode
Section 43 - Operate the e18™ PowerShift Transmission
Operate the e18™ PowerShift Transmission
Shift e18™ Transmission
Set Startup Gears
CommandCenter™ Transmission Main Page
Efficiency Manager™ on the e18™ Transmission
Custom Transmission Settings
Section 47 - Intelligent Total Equipment Control (iTEC™)
CommandARM™ Control Functions
CommandCenter™ Pages Descriptions And Functions
Status Area
Set Up A Sequence
Sequence Step Status
Execute Sequence
Delete Sequence
iTEC™ Functions—Efficiency
Manager™
Section 50 - Tractor Implement Automation™ (TIA™)
Tractor Implement Automation™ (TIA™)
Activating Tractor Implement Automation™ Equipment
TIA™ - Status Page
Operating Tractor Implement Automation™
PTO Requirements
SCV Requirements
Powershift Transmission Requirements
AutoTrac™ Guidance Requirements
Rear Hitch Requirements
Drive Strategy Requirements
Section 55 - TouchSet™ Depth Control
Attaching Implement and Control System
Using TouchSet™ Depth Controls
Section 60 - Hydraulics and Selective Control Valves
Configuring Selective Control Valves - Access to Settings
Configuring Selective Control Valves - Standard Mode
Activating Independent Mode
Configuring Selective Control Valves - Independent Mode
Configuring Selective Control Valves - Feature Mode
Total Rear SCV Flow
Using Six Position SCV Control Levers
SCV Control Lever—Neutral Position
SCV Control Lever—Extend and Extend Detent Position
SCV Control Lever—Retract and Retract Detent Position
SCV Control Lever—Float Position
Operator Presence Sensor
CommandARM™ Joystick (If Equipped)
SCV and Joystick Flow Response Setting
Section 62 - Laser Scraper Control
Laser Scraper—for Scrapers Equipped with Scraper Control
Unit
Section 63 - Remote Hydraulic Connections
Connecting Hydraulic Hoses—Rear of Tractor
Disconnecting Hydraulic Hoses—Rear of Tractor
High Flow Hydraulic Component Identification
Standard Hydraulic Component Identification
Using Load-Sensing Hydraulic System—Power-Beyond
Examples Using Load-Sensing Hydraulic System—Power-Beyond
Using Hydraulic Spray Pumps
Implement Connection Example 1—Pressure Control Valve
Applications (Grain Drills or Air Seeders with Constant Down-Pressure
System)—Less Hitch—Standard Hydraulics
Implement Connection Example 2—Motor Application Using
Motor Case Drain—Less Hitch—Standard Hydraulics
Implement Connection Example 3—Closed Center Valve, Pump
at High Pressure—Less Hitch—Standard Hydraulics
Implement Connection Example 4—Planter with Vacuum Motor
and Return Line to SCV Using Motor Return Tip—Less Hitch—Standard
Hydraulics
Implement Connection Example 5—Planter with Vacuum Motor
and Return Line to Motor Return—With Hitch—With Lift Assist—Standard
Hydraulics
Implement Connection Example 6—Planter with Vacuum Motor
and Return Line to Motor Return—With Hitch—Implement Lift
Assist—Standard Hydraulics
Connecting Implements to High Flow Hydraulic SCV's
Implement Connection Example 1—Implement Control Valves—Less
Hitch—High Flow Hydraulics
Implement Connection Example 2—Pressure Control Valve
Applications (Grain Drills or Air Seeders with Constant Down-Pressure
System)—Less Hitch—High Flow Hydraulics
Implement Connection Example 3—Closed Center Valve, Pump
at High Pressure—Less Hitch—High Flow Hydraulics
Implement Connection Example 4—Planter with Vacuum Motor
and Return Line to SCV Using Motor Return Tip—With Hitch—High
Flow Hydraulics
Using Implement Requiring Large Volumes of Oil
Recommended Scraper Hydraulic Hose Tips
Section 65 - Hitch
Rear Hitch
Hitch Control Lever
Rear Hitch Lock
Adjust Load Depth Control (Draft Response)
Using Position Control
Using Draft Control
Adjust Rear Hitch Upper Limit
Adjust Rear Hitch Drop Rate
Adjust Rear Hitch Raise Rate
Rear Hitch Slip Sensitivity
Float Operation
Hitch Components
Hitch Remote Switches
Hitch Manual Lowering
Sway Blocks
Attaching Implement to Quick Coupler
Detaching Implement From Quick Coupler
Adjusting Implement Level
Lateral Float
Hitch Conversion—Category 4/4N
Convertible Quick Coupler
Converting Category 4N/3 Convertible Quick Coupler Lower Hooks
Converting Category 4N/3 Convertible Quick Coupler Upper Hook
Section 70 - Drawbar and PTO
Stay Clear of Rotating Drivelines
Observing Drawbar Load Limitations
Category 4 Heavy Duty Drawbar Reinforcement Kit Load Limitations
(If Equipped)
Category 5 Heavy Duty Drawbar Support Load Limitations (If Equipped)
Selecting Drawbar Position
Adjusting Drawbar Side-to-Side Movement
Installing Clevis Assembly (Category 4 Drawbar)
Using Clevis Assembly (Category 4 Drawbar)
Installing Clevis Assembly (Category 5 Drawbar)
Using Clevis Assembly (Category 5 Drawbar)
Using Correct Drawbar Pin (Category 5 to 4)
Attaching PTO-Driven Implement (If Equipped)
Using PTO Master Shield (If Equipped)
Using Correct Engine Speed
Operating PTO
PTO Engagement Rate
Section 75 - Performance Ballasting
General Performance Guidelines
Determining Maximum Ballast
Worksheet to Calculate Ballast Changes
Ballasting for Engine Horsepower
Controlling Power Hop
Calculating Ballast (Tractors Without Hitch)
Calculating Ballast (Tractors With Hitch)
Unballasted Tractor Weight Chart (9370R and 9420R) — Pounds
Unballasted Tractor Weight Chart (9370R and 9420R) — Pounds (Continued)
Unballasted Tractor Weight Chart (9370R and 9420R)— Pounds (Continued)
Unballasted Tractor Weight Chart (9470R, 9520R and 9570R) — Pounds
Unballasted Tractor Weight Chart (9470R, 9520R and 9570R) —
(Continued)
Unballasted Tractor Weight Chart (9470R, 9520R and 9570R) — Pounds (Continued)
Unballasted Tractor Weight Chart (9620R) — Pounds
Unballasted Tractor Weight Chart (9620R) — Pounds (Continued)
Using Cast Hub Wheel Weights
Front Weight Frame
Implement Guidelines
Measuring Wheel Slip (Manually)
Using Liquid Ballast
Section 80 - Wheels, Tires, and Treads
Service Tires Safely
Tire Group Sizes
Tire Inflation Pressure Guidelines
Recommended Inflation Pressures—Single Tires
Recommended Inflation Pressures—Dual Tires—Group 47
Recommended Inflation Pressures—Dual Tires—Group 48
Recommended Inflation Pressures—Triple Tires
Recommended Pressures—Group 48
— IF Tires
Recommended Pressures—Group 48
— IF Tires (Continued)
Using Correct Tire Combinations
Using Dual Tires
Observing Tread Width Limitations
Tread Widths—Singles or Duals
Tread Widths—Triples
Triple Wheels (Standard Wheel Hubs)
Triple Wheels (Heavy Duty Wheel Hubs)
Installing Wheel Rim to Cast Wheel
Wheel Torque Wrench Adapter—JDG679
Wheel Weight Holding Wrench—JDG10958
Wheel Tightening Stand—DFRW219
or JDG10741
Adjusting and Tightening Wheels—Standard Cast Drive Wheel and Dual Hubs
Adjusting and Tightening Wheels—Steel Drive Wheel and Dual Standard Hubs
Adjusting and Tightening Wheels-Heavy-Duty
Drive Wheels and Dual Hubs
Adjusting and Tightening—Heavy-Duty
Dual Wheel Hubs
Using Steering Stops
Section 85 - Transport
Driving Tractor on Roads
Towing Loads and Transporting with Ballast
Use Safety Lights and Devices
Transporting Rear Mounted Implements with Ballast
Using Safety Chains
Transporting on Carrier
Towing—Rear Wheels Off Ground
Towing with All Wheels on Ground—Engine Will Start
Towing with All Wheels on Ground—Engine Will Not Start
Freeing a Mired Tractor
Section 90 - Fuels, Lubricants, and Coolants
Diesel Fuel
Supplemental Diesel Fuel Additives
Lubricity of Diesel Fuel
Handling and Storing Diesel Fuel
Avoid Static Electricity Risk When Refueling
Filling Fuel Tank
BioDiesel Fuel
Testing Diesel Fuel
Fuel Filters
Minimizing the Effect of Cold Weather on Diesel Engines
Filling Diesel Exhaust Fluid (DEF) Tank - FT4/Stage IV Engines
Diesel Exhaust Fluid (DEF) — Use in Selective Catalytic
Reduction (SCR) Equipped Engines
Storing Diesel Exhaust Fluid (DEF)
Refilling Diesel Exhaust Fluid (DEF) Tank
Testing Diesel Exhaust Fluid (DEF)
Disposal of Diesel Exhaust Fluid (DEF)
John Deere Break-In Plus™ Engine Oil — Final Tier
4 and Stage IV 9.0 and 13.5 L Engines
Break-In Engine Oil Use — Final Tier 4 and Stage IV 15.0
L Engines
Determining Tractor Engine Type
Diesel Engine Oil — Interim Tier 4, Final Tier 4, Stage
IIIB, and Stage IV
Engine Oil and Filter Service Intervals — Final Tier 4
and Stage IV 9.0 and 13.5 L Engines
Engine Oil and Filter Service Intervals — Final Tier 4
and Stage IV 15.0 L Engines
Diesel Engine Oil — Tier 2 and Stage II
Engine Oil and Filter Service Intervals — Tier 2 and Stage
II Engines
Oil Filters
Diesel Engine Coolant (engine with wet sleeve cylinder liners)
John Deere COOL-GARD™ II Coolant Extender
Operating in Warm Temperature Climates
Water Quality for Mixing with Coolant Concentrate
Testing Coolant Freeze Point
Disposing of Coolant
Transmission/Axle and Hydraulic Oil
Grease
Mixing of Lubricants
Alternative and Synthetic Lubricants
Lubricant Storage
Section 92 - Break-In Service (100 Hours or Less)
Perform Break-In Checks
Section 95 - Maintenance and Service Intervals
Observe Service Intervals
Service Interval Chart—Daily or
10 Hour, 50 Hour, 250 Hour, 400 Hour, 500 Hour and 1000 Hour
Service Interval Chart—Annual,
1500 Hour, 2000 Hour, 3000 Hour, 4500 Hour, 5000 Hour and 6000 Hour
Section 100 - As Indicated Service
Perform As Indicated Service
Replace Primary And Secondary Engine Air Filters
Check Coolant Level
Clean Diesel Particulate Filter (DPF)
Drain Optional Fuel/Water Separator (If Equipped)
Drain Water Separator
Section 103 - As Required Service
Perform As Required Service
Clean Radiator, Coolers, and Air Conditioning Condenser- 9.0
and 13.5 L Engines
Clean Radiator, Coolers, and Air Conditioning Condenser- 15.0
L Engine
Check Engine and Exhaust Compartments for Debris
Inspect Outer Exhaust Screens
Check Air Conditioning System
Remove and Install Vari-Cool™ Fan Belt (9.0 L FT4 Engines)
Remove and Install Vari-Cool™ Fan Belt (13.5 L FT4 Engines)
Replace Auxiliary Drive Belt - 15.0 L Engine
Replace Fan Belt - 9.0 and 13.5 Tier II / Stage II Engines Only
Check Weep Hole—9.0 L Engine
Check Weep Hole—13.5 L Engine
Check Water Pump Seal— 15.0 L Engine
Drain Fuel Tank Sump
Cleaning Diesel Exhaust Fluid (DEF) Tank
Clean Diesel Exhaust Fluid (DEF) Tank Filler Neck Filter
Section 105 - Daily or 10 Hour Service
Check Engine Oil (9.0 L Engine)
Check Engine Oil (13.5 L Engine)
Check Engine Oil- Cummins™ Engine (15.0 L Engine)
Check Transmission/Hydraulic Reservoir/Axle Oil Level
Lubricate HydraCushion™ Front Axle Suspension (If Equipped)
Section 110 - 50 Hour Service
Perform This and Other Scheduled Services
Inspect Tires
Lubricate Rear Hitch Components (If Equipped)
Lubricate Hinge Pins
Lubricate Steering Pin Bushings (If Equipped)
Section 115 - 250 Hour Service
Perform This and Other Scheduled Services
Check Manual Brakes
Check Neutral Start System
Check Transmission PARK System
PST Lubricate Telescoping Drive Shafts
Lubricate PTO Drive Shaft (If Equipped)
Lubricate Heavy-Duty Gudgeon Bearings (If Equipped)
Lubricate Lower Drive Line Bearings
Lubricate Rear Hitch Components (If Equipped)
Lubricating Lift Cylinders and Rockshaft
Section 117 - 400 Hour Service
Perform This and Other Scheduled Services
Change Engine Oil and Filter—15.0
L Engine
Replace Fuel Filter Elements — 15.0 L Engine
Section 120 - 500 Hour Service
Perform This and Other Scheduled Services
Change Engine Oil and Filter — 9.0 L Engine
Change Engine Oil and Filter — 13.5 L Engine
Lubricate Vari-Cool™ Fan Drive (9.0 and 13.5 Final Tier
4 and Stage IV Engines Only)
Tighten Wheel and Wheel Weight Bolts
Lubricate HydraCushion™ Front Axle Suspension (If Equipped)
Inspect Drawbar Support and Cap Screws
Clean Dual Beam Radar Sensor (If Equipped)
Replace Fuel Filter Elements — 9.0 L Engine
Replace Fuel Filter Elements — 13.5 L Engine
Inspect Air Intake System- 9.0 L FT4/Stage IV Engine
Inspect Air Intake System- 9.0 L Tier II/Stage II Engine
Inspect Air Intake System- 13.5 L FT4/Stage IV Engine
Inspect Air Intake System- 13.5 L Tier II/Stage II Engine
Inspect Air Intake System- 15.0 L FT4/Stage IV Engine
Back Flush Optional Fuel Water Separator (If Equipped)
Service Severe Duty Fuel Water Separator (If Equipped)
Lubricate Rear Hitch Draft Sensor (If Hitch-Equipped)
Section 125 - 1000 Hour Service
Perform This and Other Scheduled Services
Replace Cab Fresh Air Filters and Recirculation Filters
Test Coolant Freeze Point
Section 130 - Annual Service
Handling Batteries Safely
Service Batteries and Connectors
Service Batteries and Connectors- 15.0 L Engine
Change Engine Oil and Filter
Test Coolant Freeze Point
Inspect Seat Belts
Replace Cab Recirculation and Fresh Air Filters
Replace Primary and Secondary Engine Air Filters
Check HydraCushion™ Suspended Front Axle Accumulator Charge
Pressure (If Equipped)
Section 135 - 1500 Hour Service
Perform This and Other Scheduled Services
Replace e18™ Powershift Vent Filter
Replace Fuel Tank Vent Filters
Replace Diesel Exhaust Fluid (DEF) Tank Vent Filter- FT4/Stage
IV Engines
Change Transmission/Hydraulic Reservoir Suction Screens/Axle
Oil and Filters
Clean Aftertreatment Fuel Injector (15.0 L Engine)
Replace Radiator Pressure Cap (15.0 L Engine)
Inspect Auxiliary Drive Belt and Drive Belt Tensioner - 15.0 L Engine Only
Check HydraCushion™ Suspended Front Axle Accumulator Charge
Pressure (If Equipped)
Check Axle End Play
Section 140 - 2000 Hour Service
Perform This And Other Scheduled Services
Adjust Engine Valve Clearance (Tier 2 and Stage II 9.0 L and
13.5 Engines Only)
Section 142 - 3000 Hour Service
Change Crankcase Breather Filter Element (15.0 L Engine)
Adjust Engine Valve Clearance (9.0 , 13.5, and 15.0 L FT4/Stage
IV Engines)
Replace Transmission Drive Shaft Damper
Section 145 - 4500 Hour Service
Perform This and Other Scheduled Services
Access Diesel Exhaust Fluid (DEF) Dosing Unit and Tank Vent
Filters - Final Tier 4 and Stage IV Engines
Changing Diesel Exhaust Fluid (DEF) Dosing Unit Filter
Replace Transmission Drive Shaft Damper
Section 148 - 5000 Hour Service
Perform This and Other Scheduled Services
Replace Engine Crankshaft Damper (9.0 and 13.5 L Tier II and
Stage II Engines)
Section 150 - 6000 Hour Service
Perform This and Other Scheduled Services
Draining, Flushing and Refilling Cooling System—9.0L Engine
Draining, Flushing and Refilling Cooling System—13.5L Engine
Draining, Flushing and Refilling Cooling System—15.0 L Engine
Section 155 - General Service
Jack Up the Tractor - Lifting Points and Support Stand Placement
(2010-52-EU)
Servicing and Connecting Snap to Connect STC® Fittings
Using High-Pressure Washers
Diesel Particulate Filter Service
Exhaust Filter / Diesel Particulate Filter Ash Handling and
Disposal
Exhaust Filter Disposal
Transmission Calibration
Aborting Transmission Calibration
Do Not Modify Fuel System
Do Not Open High-Pressure Fuel System
Bleed Fuel System
Identify Zinc-Flake Coated Fasteners
Metric Bolt and Screw Torque Values
Unified Inch Bolt and Screw Torque Values
Section 160 - Electrical System Service
Introduction to Electrical Service Section
Disconnect Battery - Final Tier 4 and Stage IV Engines
Load Center Fuses
Master Fuse
Welding Near Electronic Control Units
Keep Electronic Control Unit Connectors Clean
Using Compressed Air
Using High-Pressure Washers
Replace Implement Power Relay Module Fuses
Handle Halogen Light Bulbs Safely
Replace Front HID/LED Light Assembly
Replace Front Grille Halogen Light Bulbs
Adjust Front Grille Lights
Aim Headlights
Replace Front, Side And Rear Cab Roof Light Assembly
Replace Brake or Turn Signal Light Bulb
Replace Dome Light Bulb
Replace Courtesy Light Bulb
Replace Map Light Bulb
Replace Extremity Warning Light Bulb (If Equipped)
Section 165 - Troubleshooting
Engine Troubleshooting
Transmission-Hydraulic-Axles Troubleshooting
Hydraulic System Troubleshooting
Brakes Troubleshooting
Hitch Troubleshooting
Selective Control Valve Troubleshooting
Electrical System Troubleshooting
Operator Enclosure Troubleshooting
Section 170 - Diagnostic Trouble Codes
STOP, Service Alert, and Information Indicators
Accessing Diagnostic Trouble Codes
Section 175 - Storage
Place Tractor in Storage
Remove Tractor from Storage
Paint Finish Care
Section 180 - Specifications
Engine: John Deere™
Engine: QSX15 Cummins®
Capacities
Hydraulics
Electrical
Hitch, Drawbar, and PTO
Transmission and Power Train
Other Equipment
Overall Dimensions
Ground Speeds—e18™ Powershift
Transmission
EPA Non-road Emissions Control Warranty Statement—Compression
Ignition
CARB Non-road Emissions Control Warranty Statement—Compression
Ignition
Cummins QSX15 — EPA Non-road Emissions Control Warranty
Statement
Cummins QSX15 — CARB Non-road Emissions Control Warranty
Statement
Limited Battery Warranty
Section 185 - Identification Numbers
Identification Plates
Record Product Identification Number
Record Engine Serial Number
Record Cab Serial Number
Record Transmission Serial Number
Record PTO Dropbox Serial Number
Record PTO Clutch Serial Number
Keep Proof of Ownership
Keep Machines Secure
Section 190 - Lubrication and Maintenance Records
50 Hour Service Records
250 Hour Service Records
400 Hour Service Records
500 Hour Service Records
1000 Hour Service Records
Annual Service Records
1500 Hour Service Records
2000 Hour Service Records
3000 Hour Service Records
4500 Hour Service Records
5000 Hour Service Records
6000 Hour Service Records
Section 195 - Glossary
Glossary of Terms
Section SLIT - John Deere Service Literature Available
Technical Information
Section IBC - John Deere Service Keeps You on the Job
John Deere Is At Your Service